Abstract:During high pressure processing, the adiabatic compression increase of food materials would cause non-uniform temperature distribution and heat transfer, which would also influence the inactivation of bacteria, spore, enzyme and the quality of foods. Thermal conductivity of food materials at high pressure is a very important parameter for understanding heat transfer and temperature variation during high pressure processing. Available data and measuring method of thermal conductivity of food materials under high pressure are still scarce. In this study, a thermal conductivity probe developed based on the line heat source theory was installed in a high pressure chamber to measure thermal conductivity of food materials under high pressure. The thermal conductivity probe was calibrated using 1.5% agar gel whose thermal conductivity was very close to that of pure water but the convective effect during the measurement was eliminated due to the gel network at pressure from 0.1 to 400 MPa with a pressure increment of 50 MPa. The results of calibration experiment indicated that thermal conductivity values of 1.5% agar gel measured under different pressures using the thermal conductivity probe were very close to that of reference data of pure water. Calibration factors defined as the ratio of measured and reference values of the thermal conductivity of 1.5% agar gel were found almost no effect by pressure. A general calibration coefficient value of 0.9944 (R square was 0.9997, observation number was 30) was obtained by linear regression analysis (zero intercept) of measured thermal conductivity values of 1.5% agar gel against reference values of pure water. The coefficient value was used for the correction of all experimental results in the following. Thermal conductivities of egg white, egg yolk, ham sausages and cream were measured at pressure from 0.1 to 400 MPa with a pressure increment of 50 MPa. The results demonstrated that the thermal conductivities of these selected food materials at high pressure conditions were higher (up to 28%) than that of the sample at the atmospheric pressure conditions and had a tendency to increase with increasing pressure. Results at atmospheric pressure in this study were compared to estimate values using empirical equation based on water content. The measured thermal conductivities of egg yolk (0.43 W/(m·℃)), ham sausages (0.45 W/(m·℃)) and cream (0.49 W/(m·℃)) were very close to the estimated values (egg yolk 0.40 W/(m·℃), ham sausages 0.43 W/(m·℃), cream 0.41 W/(m·℃)) , while the measured value of egg white (0.65 W/(m·℃)) was significantly higher than that of the estimated value (0.53 W/(m·℃)) as well as that of pure water. The reason probably was that the flowability of egg white caused the generation of convective heat transfer. Measured thermal conductivities of egg white decreased at pressure higher than 300 MPa which was different from other three materials. The reason probably was that the pressure processing more than 300 MPa induced coagulation of egg white resulting in decrease of flowability as well as convective heat transfer. The water content of food materials had a significant effect on thermal conductivity. In general, the higher the water content, the higher the thermal conductivity. This rule was also confirmed at high pressure as the thermal conductivity from highest to lowest in order being egg white (83.1% water) > ham sausages (63.5%) > cream (57.5%) > egg yolk (50.7%). An empirical equation was established for prediction of the thermal conductivity of food materials at high pressure. The fourth-order polynomial was used to fit the thermal conductivity values of egg white, egg yolk, ham sausages and cream at pressure range from 0.1 to 400 MPa with temperature of 25℃. The regression coefficients of these equations were all above 0.91. This study could provide basic scientific datas for high pressure processing of food materials.

The Sterilization Results of Dense Phase Carbon Dioxide on Liquid Egg White and the Effect on Physicochemical and Functionial Properties

The effect of dense phase carbon dioxide on the conformation of hemoglobin

Effect of combined electrolyzed reduced water and slightly acidic electrolyzed water spraying on the control of Salmonella, eggshell quality, and shelf life of eggs during storage

Effects on the functional properties of Pasteurized liquid whole egg by freezing storage

Key Process of Egg Curd Using Liquid Egg White

Effects on microbial inactivation and quality attributes in frozen lychee juice treated by supercritical carbon dioxide

Improvement of Foaming Characteristics and Stability of Sterilized Liquid Egg with Egg White Hydrolysate (EWH)

Effect of High Pressure on Inactivation of Escherichia Coli in Frozen Suspension

Ultra High Pressure Increasing Thermal Conductivity of Food Materials

Effects of the Application of Dense Phase Carbon Dioxide Treatments on Technological Parameters, Physicochemical and Textural Properties and Microbiological Quality of Lamb Sausages

The effect of different drying methods on some physico-chemical, functional and protein structure properties of liquid egg white fermented by Lactobacillus rhamnosus GG

Irradiation-Assisted Enhancement of Foaming and Thermal Gelation Functionality of Liquid Egg White

Mechanistic study on the decline of foaming characteristics of egg white under heat stress: Emphasizing apparent phenomena, structure, and intermolecular interactions

Effect of dense phase carbon dioxide treatment on physicochemical and textural properties of pickled carrot

The Effect of Different in Liquid Egg Yolk Storage Temperature on Physical, Chemical, Microbiological and Functional Properties

Combined Effect of High Pressure and Slightly Acidic Electrolyzed Water on Sterilization of Fresh-cut Fruits and Vegetables

EFFECTS OF MINIMAL PROCESSING AND VITAMIN C ENRICHMENT ON MICROBIOLOGICAL SAFETY AND VISCOSITY OF LIQUID EGG WHITE

Changes in microbial, physiochemical, and functional properties of pasteurized liquid whole egg during refrigerated storage

Effects of Sterilization Treatments on the Analysis of TOC in Water Samples.

Influence of atmospheric-pressure cold plasma-induced oxidation on the structure and functional properties of egg white protein