Abstract:Polyvinylidene fluoride (PVDF)–perfluorosulfonic acid (PFSA) blend hollow fiber ultrafiltration (UF) membranes were prepared by wet-spinning method using pure water as an external coagulation solution. Coagulation kinetics of PVDF–PFSA–DMAc system was measured by light transmittance experiment. Using PEG10000 (Mw=10,000), lysozyme (Mw=14,400), PEG20000 (Mw=20,000) and BSA (Mw=67,000), the separation performances of PVDF–PFSA blend hollow fiber UF membranes were obtained. Based on the experimental results, the delayed demixing process was observed for the dope solution M-1 without PFSA-H while the instantaneous demixing process was observed for the others with PFSA-H in the dope solutions M-2 to M-6. The precipitation rate increased with the increment of the PFSA-H concentration in PVDF–PFSA dope solution. The bore fluid solution with 95:5 DMAc:H2O resulted in single finger-like voids for PVDF–PFSA-H UF membrane. The pure water permeation flux of PVDF–PFSA-H UF membranes firstly increased from <0.1×10−5 to 119.1×10−5Lm−2h−1Pa−1 (<0.1 to 119.1Lm−2h−1bar−1) for M-1 to M-4(1) and 137×10−5Lm−2h−1Pa−1 (137Lm−2h−1bar−1) for M-4(2), and decreased from 119.1×10−5 to 79×10−5Lm−2h−1Pa−1 (119.1 to 79Lm−2h−1bar−1) for M-4(1), M-5 and M-6 as the PFSA-H concentration changed from 0% to 5% and total PVDF–PFSA-H concentration was 20wt.%. The molecular weight cut-off (MWCO) of PVDF–PFSA blend hollow fiber UF membranes spun from 20wt.% PVDF–PFSA-H concentration with 3–5wt.% PFSA-H was about 20,000 while that spun from 22wt.% PVDF–PFSA-H or PVDF–PFSA-Na concentration with 5wt.% PFSA-H or PFSA-Na was about 10,000. As the WPFSA-H/WPVDF increases from 2/18 to 5/15 for M-3–M-6, JBSA/Jw increases from 0.53 to 0.79. The anti-fouling property of PVDF–PFSA-H blend UF membrane is superior to PVDF–PFSA-Na blend membrane. Based on FTIR spectra, PFSA-H existed in PVDF–PFSA blend hollow fiber UF membranes. There is no obvious variation of the intensity of the characteristic peak at 983cm−1 assigned to C–O–C group of PFSA-H molecules. This also illustrated that PVDF–PFSA-H blend hollow fiber UF membranes were stable.

Effect of Perfluorosulfonic Acid(PFSA)Content on the Performance of Polyvinyl Chloride-Perfluorosulfonic Acid(PVC-PFSA)Hollow Fiber Blend Ultrafiltration Membrane

Effect of Bore Fluid Composition on the Performance of PVC-PFSA Hollow Fiber Blend Membrane

Synthesis of PVC-b-PEG Copolymer and Its Modification Effect on PVC Microfiltration Membrane

Fabrication and Performance of a Low Operating Pressure Nanofiltration Poly(vinyl Chloride) Hollow Fiber Membrane

Improved Antifouling Properties of Polyvinyl Chloride Blend Membranes by Novel Phosphate Based-Zwitterionic Polymer Additive

Preparation of Positively-Charged Blend PVC/PEI Ultrafiltration Membranes with Crosslink Structure for Dye/Salt Separation

Poly(vinyl chloride) (PVC) hollow fiber ultrafiltration membranes prepared from PVC/additives/solvent

Morphology and Performance of Polyvinylidene Fluoride/Perfluorosulphonic Acid Hollow Fibre Ultrafiltration Blend Membranes

Effect of Performance of Polyvinyl Chloride (PVC) UF Membranes Modified by Poly (Vinylidene Chloride-Acrylonitrile-Methyl Methacrylate)

Preparation and characterization of PVDF–PFSA blend hollow fiber UF membrane

Improved permeability and antifouling properties of polyvinyl chloride ultrafiltration membrane via blending sulfonated polysulfone

Preparation and Characterization of PVDF-PFSA Flat Sheet Ultrafiltration Membranes

Characterization of PVDF–PFSA hollow fiber UF blend membrane with low-molecular weight cut-off

Morphology and Properties of Perfluorosulfonic Acid Polymer/Perfluorocarboxylic Acid Polymer Blend Membranes

Preparation and characterization of a PFSA–PVDF blend nanofiber membrane and its preliminary application investigation

Optimizing the Molecular Weight of Poly(vinylidene Fluoride) for Competitive Perfluorosulfonic Acid Membranes

The Contrastive Study Of Chemical Treatment On The Properties Of Pvdf/Pfsa And Pvdf/Pvp Ultrafiltration Membranes

pH-Responsive Poly(vinyl chloride) Ultrafiltration Membranes Modified by Poly(vinyl chloride)-Poly(acrylic acid) Block Copolymers

Effect of Different Additives on Morphology and Properties of Poly(Vinylidene Fluoride) Membrane

Poly(vinylidene Fluoride) Ultrafiltration Membranes Containing Hybrid Silica Nanoparticles: Preparation, Characterization and Performance

Study of poly(vinyl chloride)/polyether sulphone co-blend ultrafiltration membrane