Abstract:Uniform, large-scale, and well-aligned needle-like ZnO nanorods with good photoluminescence and photocatalysis properties on Zn substrates, have been successfully fabricated using a simple low-temperature seed-layer growth approach in solution (50 °C). The formation of ZnO seed-layer by the anodic oxidation technique (AOT) plays an important role in the subsequent growth of highly oriented ZnO nanorods arrays. Temperature also proved to be a significant factor in the growth of ZnO nanorods and had a great effect on their optical properties. X-ray diffraction (XRD) analysis, selected-area electron diffraction (SAED) pattern and high-resolution TEM (HRTEM) indicated that the needle-like ZnO nanorods were single crystal in nature and that they had grown up preferentially along the [0001] direction. The well-aligned ZnO nanorods arrays on Zn substrates exhibited strong UV emission at around 380 nm at room temperature. To investigate their potential as photocatalysts, degradation of pentachlorophenol (PCP) in aqueous solution was carried out using photocatalytic processes, with comparison to direct photolysis. After 1 h, the degradation efficiencies of PCP by direct photolysis and photocatalytic processes achieved 57% and 76% under given experimental conditions, respectively. This improved degradation efficiency of PCP illustrates that ZnO nanorods arrays on Zn substrates have good photocatalytic activity. This simple low-temperature seed-layer growth approach in solution resulted in the development of an effective and low-cost fabrication process for high-quality ZnO nanorods arrays with good optical and photocatalytic properties that can be applicable in many fields such as photocatalysis, photovoltaic cells, luminescent sensors, and photoconductive sensors.

Seed layer-free electrodeposition and characterization of vertically aligned ZnO nanorod array film

Conversion of large-scale oriented ZnO rod array into nanotube array under hydrothermal etching condition via one-step synthesis approach

Effect of Electrodeposition Time on Microstructure, Wettability and Optical Properties of ZnO Nanorod Arrays

A large-scale-oriented ZnO rod array grown on a glass substrate via an in situ deposition method and its photoconductivity

Fabrication and Characterization of Vertically Aligned ZnO Nanorod Arrays via Inverted Monolayer Colloidal Crystals Mask

Preparation of ZnO Nanorod Arrays by Seed-assisted Chemical Bath Deposition Method

Zno Nanorod Arrays with Tunable Size and Field Emission Properties on an Ito Substrate Achieved by an Electrodeposition Method

Selective Growth of Vertical-aligned ZnO Nanorod Arrays on Si Substrate by Catalyst-free Thermal Evaporation

Alignment-controlled Hydrothermal Growth of Well-Aligned ZnO Nanorod Arrays

One-step electrodeposition of single-crystal ZnO nanotube arrays and their optical properties

Seed-Layer Effect on Highly Oriented ZnO Nanorod Array Fabrication

Controlled Growth of ZnO Array on FTO Glass Substrate by Electrodeposition

Fabrication of needle-like ZnO nanorods arrays by a low-temperature seed-layer growth approach in solution

General Route to Zno Nanorod Arrays on Conducting Substrates Via Galvanic-Cell-Based Approach

Substrate effect on Electrodeposition of ZnO nanorod Arrays

Hydrothermal Growth of Perpendicularly Oriented Zno Nanorod Array Film and Its Photoelectrochemical Properties

Highly Oriented 1-D Zno Nanorod Arrays on Zinc Foil: Direct Growth from Substrate, Optical Properties and Photocatalytic Activities

Catalyst-Free Growth and Optical Properties of Vertically Aligned ZnO Nanorod Arrays on Si Substrates Covered with Thin Buffer Layers

Growth of Zno Nanorod Arrays on Soft Substrates by Hydrothermal Process

Growth of vertically aligned ZnO nanorods using textured ZnO films

Low-temperature hydrothermally grown 100 μm vertically well-aligned ultralong and ultradense ZnO nanorod arrays with improved PL property