Abstract:Conventional wet-process phosphoric acid (WPA) extraction route encounters unsatisfactory extraction efficiency, phosphorus yield, and raffinate utilization. Herein, a new extraction route for H3PO4 separation from wet-process superphosphoric acid (WSPA) is proposed to improve these dilemmas. We focus on the equilibrium of H3PO4 extraction by tributyl phosphate (TBP) from WSPA and the extraction mechanism of TBP under high H3PO4 loading conditions. Several critical factors affecting the extraction equilibrium were investigated to optimize the extraction process, including the initial phase ratio (R0), the volume fraction of TBP in extradant (φTBP), temperature (T), and the crosscurrent extraction stages. The results show that the single-stage extraction rate of H3PO4 reaches 70% at R0=6, φTBP=80% and T=80oC with separation factors βP/Fe, βP/Al, βP/Mg, and βP/Ca of 12.48, 21.66, 47.57, and 8.89, respectively. In addition, Fourier transform infrared spectroscopy and Raman spectroscopy enlighten the extraction mechanism at high loading conditions. The characteristic peak positions of P=O, P=O⋯H2O, and P=O⋯H3PO4 in the infrared spectra are determined to be centered at 1,283, 1,267, and 1,233 cm−1, respectively. The semi-quantitative analysis implies that the self-polymerization behavior of the extraction complex TBP·H3PO4 and the mutual attraction of reverse micelles (RMs) through their polar cores is the trigger for the formation of a third phase. Furthermore, the red shift of P-(OH)3 asymmetrical stretching vibration in the Raman spectrum indicates the formation of hydrogen bonds among H3PO4 molecules in the organic phase, which corroborates the formation of RMs. Conclusions can be obtained that H3PO4 enters the organic phase under high loading capacity by reversed micellar extraction. The feasibility of this extraction process is further tested by scrubbing, stripping, and cycling performance experiments. The results are promising for the design of a new efficient route for separating H3PO4 from WPA.

STUDY ON SOLIDIFICATION OF SPENT TRIBUTYLPHOSPHATE

Molecular Modification of a Novel Macroporous Silica-Based Impregnated Polymeric Composite by Tri-N-butyl Phosphate and Its Application in the Adsorption for Some Metals Contained in a Typical Simulated HLLW.

Solidification of 30% Tbp-Ok Waste by Calcium Sulfoaluminate Cement

Technological process for treating radioactive TBP/OK spent solvents

Treatment of Spent Solvent by Mediated Electrochemical Oxidation

Treatment of Tributyl Phosphate by Fenton Oxidation: Optimization of Parameter, Degradation Kinetics and Pathway

Study on solubility parameter of TBP/MIBK and phase equilibrium of TM/H3PO4/H2O

Solidification of Tannery Sludge with Various Binders

Treatment of 2,4,6-tribromophenol-contaminated water using iron ion/calcium sulfite: The dual role of oxidation and coagulation

Solidification Mechanism and Strength Characteristics of Alkali-Activated Tannery Sludge–Slag Geopolymer

Carbon and Hydrogen Stable Isotope Analysis for Characterizing the Chemical Degradation of Tributyl Phosphate.

In-situ solidification/stabilization of heavy metals contaminated site soil using a dry jet mixing method and new hydroxyapatite based binder

Recovery of phenolic compounds from phenol-containing wastewater by complexation extraction treatment Ⅰ.Recovery of caustic phenolic compounds from waste caustic sludge in oil refinery

Low-carbon and low-alkalinity stabilization/solidification of high-Pb contaminated soil

Stabilization and solidification technology for treating heavy oil-contaminated sediments

Effect of thermal hydrolysis pretreatment on the stabilization of sludge with different solid contents during autothermal thermophilic aerobic digestion

Efficient Electrochemical Degradation of TBP Using a Ti/SnO2-Sb/F-PbO2 Electrode

Solidification and Stabilization of Spent Pine-cone Biochar using Chemically Bonded Phosphate Cement

Solidification of spent radioactive organic solvent by sulfoaluminate and Portland cements

Acid treatment on dewatered sewage sludge followed by cement-based solidification

A non-aqueous phase extraction system using tributyl phosphate for H3PO4 separation from wet-process superphosphoric acid: Extraction equilibrium and mechanism