Abstract:Different membranes covering the macroporous to nano-pororous range and having different porosities have been used to study the mass transfer of methane and carbon dioxide single gases. The effect of flow parameters on the transport mechanisms through porous membranes were reviewed in detail. The characteristics of gas transport through the macroporous, microporous, and nano-porous membranes were investigated with several gas diffusion models in the range of 20–100 ◦C and at pressure differences ranging from 0.2 to 3 bar. The experimental gas permeation data of the membranes were analyzed using the Darcy flow model. The results clearly showed good agreement between the model analysis and the experimental data. The experimental data showed that the permeation followed a parallel flow model in which the behavior of gases was governed by viscous and Knudsen diffusion, although to varied degrees. Permeation of the gases through each membrane varies considering the viscosity of the gases at the same temperature. Furthermore, the membranes followed the configurational diffusion model in which the permeance increased with increasing pressure and decreasing temperature. For the gas flow measurements through macroporous and nano-porous membranes with diameters ranging from 6000nm to 15nm, the results indicate that the experimental flux agrees well with the calculated (model) flux through which gas flows from the bulk stream in the shell side to the membrane outer surface where viscous flow and Knudsen diffusion coexist. The study shows that experimental flux is larger than Knudsen diffusion, and the contribution of Knudsen diffusion to the experimental flux increases with the decrease in the diameter. On the other hand, the effects of gas slippage are considerable as gas velocity near the wall is higher than zero. The slip length effects are inversely proportional to pore size and with driving pressure.

Study on Permeation of Acetone/Nitrogen Mixed Gas Through Al2o3 Microporous Membranes: Molecular Dynamics

Molecular dynamics simulation on permeation of acetone/nitrogen mixed gas through Al2O3 microporous membranes

CO2 Facilitated Transport Through an Acrylamide and Maleic Anhydride Copolymer Membrane

Formation Mechanism of Ordered Porous Nitrocellulose Membranes by Breath Figure Templating

Non-equilibrium Molecular Dynamics Simulation on Pure Gas Permeability Through Carbon Membranes

Copolymer Membrane Preparation of 2-(N,n-dimethyl Aminoethylme) and Acrylonitrile and Its Gas Permeance Performance

Study of the Dissolution and Diffusion of Propane, Propylene and Nitrogen in Polydimethylsiloxane Membranes with Molecular Dynamics Simulation and Monte Carlo Simulation

Selective Permeation of CO2 Through a Composite Membrane with a Separation Layer of 2-N,n-dimethyl Aminoethyl Methacrylate and Acrylic Acid Copolymer

Mass Transfer Characteristics through Alumina Membranes with Different Pores Sizes and Porosity

Effect of Temperature on the Permeation and Separation of Oxygen and Nitrogen in Carbon Membranes: A Non-equilibrium Molecular Dynamics Simulation Study

Grand Canonical Monte Carlo and Non-Equilibrium Molecular Dynamics Simulation Study on the Selective Adsorption and Fluxes of Oxygen/nitrogen Gas Mixtures Through Carbon Membranes

Molecular Dynamics Simulation for Separation Performance of PDMS/Fluorosilane Membrane with Different Mass Ratios in Acetone‐Water Mixture

AlPO-18 Membranes for CO2/CH4 and N2/CH4 Separations

Molecular Dynamics Simulation of Transport and Separation of Carbon Dioxide–Alkane Mixtures in a Nanoporous Membrane Under Sub- and Supercritical Conditions

Permeation of Compressed and Supercritical Fluids Through Porous Membranes

Molecular Dynamics Study of Nitrogen in Slit Micropores

Microporous Adsorbent-Based Mixed Matrix Membranes for CO2/N2 Separation

Permeation of CO2 and CH4 Through a 2-(N,n-dimethyl Amino) Ethyl Methacrylate and Acrylonitrile Copolymer Membrane

Transport Study of Pure and Mixed Gases Through PDMS Membrane

Separation of azeotrope acetone-methanol mixture at high-concentration conditions: Experimental and theoretical perspective of the molecular packing effects in mesopores

Molecular dynamics simulations of transport and separation of supercritical carbon dioxide-alkane mixtures in supported membranes