Abstract:In the present study, the bubble growth, departure and the following flow pattern evolution during flow boiling in the mini-tube were visualized and quantitatively investigated, along with the simultaneous measurement of the local heat transfer coefficient around a specified nucleation site. Liquid nitrogen was employed as the working fluid and the test section was a segment of vertically upward quartz glass tube with the inner diameter range of 1.3–1.5mm, which was coated by a layer of transparent ITO film as the heater on the outer surface. The growth rates of bubbles had similar and constant growth rate in two periods of time, i.e., before and after the bubbles departing from the nucleation site, which indicated the bubble growth was primarily governed by the inertial force. The bubble departure diameter and bubble period were investigated and the corresponding correlation was obtained based on the experimental data, which showed that the tube size of the mini-tube had no notable effect on the bubble departure and the trend of the bubble departure was similar to that in macro-tubes. Whereas the following flow pattern evolution was apparently confined due to the size effect, which presented desirable heat transfer performance in mini-tubes. The heat transfer coefficients for different flow patterns along the mini-tube were obtained in terms of bubbly, slug, annular flow and the flow regimes of flow reversal and post dryout. It was found that the dominant heat transfer mechanism was the liquid film evaporation which offered desirable heat transfer capability. The heat transfer performance would be deteriorated in the post dryout regime, while flow reversal could somewhat enhance the heat transfer upstream of the nucleation site. Boiling curves around the specified nucleation site were recorded and analyzed based on the recorded flow patterns.

Visualization of flow boiling of liquid nitrogen in a vertical mini-tube

Visual Study of Flow Pattern Evolution of Flow Boiling in A Microtube

Flow Patterns and Flow Regime Maps of Liquid Nitrogen Flow Boiling in Micro/mini-channels

Observation and Analysis of the Detachment Frequency of Coalesced Bubbles in Pool Boiling Liquid Nitrogen

Two-phase flow characteristics of liquid nitrogen in vertically upward 0.5 and 1.0mm micro-tubes: Visualization studies

Flow Boiling Patterns Of Liquid Nitrogen In Micro-Tubes

Flow Boiling of Liquid Nitrogen in Micro-Tubes：two-phase Flow Pressure Drop

Flow boiling of liquid nitrogen in a horizontal macro-tube at low pressure: Part I - flow pattern, two-phase flow instability, and pressure drop

Bubble growth, departure and the following flow pattern evolution during flow boiling in a mini-tube

Flow and Heat Transfer Characteristics of Liquid Nitrogen in Mini-/Microchannels

Experimental Study on Boiling Flow of Liquid Nitrogen in Vertical Tubes: Taylor Bubble Length Distribution and Rising Velocity

Flow Boiling Instability of Liquid Nitrogen in Horizontal Mini Channels

Visualization of Flow Boiling Experiments on Micro/Nanoscale Structured Surfaces in Microchannel

FLOW BOILING OF LIQUID NITROGEN IN MICRO-TUBE——TWO-PHASE HEAT TRANSFER ANALYSIS

Flow boiling of liquid nitrogen in micro-tubes: Part II – Heat transfer characteristics and critical heat flux

Studies of gas-liquid two-phase flows in horizontal mini tubes using 3D reconstruction and numerical methods

Visualization Study on Bubble Dynamical Behavior in Subcooled Flow Boiling under Various Subcooling Degree and Flowrates

Flow Behavior Around Single Nucleate Boiling Bubble Quantitatively Grasped by Particle Tracking Visualization

Experimental heat transfer results and flow visualization of horizontal Near-Saturated liquid nitrogen flow boiling in uniformly heated circular tube under Earth gravity

Numerical investigation on boiling flow of liquid nitrogen in a vertical tube using bubble number density approach

Visual experimental investigation of natural circulation boiling of nitrogen in a vertical annular