Abstract:Composting pretreatment has been widely used in biogas plant of agricultural straw for improving biotransformation rate of lignocellulosic materials. However, the mechanisms on composting pretreatment of agricultural straw for biogas production need more research. In this study, two experiments were conducted to evaluate the impacts of composting pretreatment on biogas production of wheat straw. In the first experiment, the wheat straw was directly used for composting and then composted straw was used in the biomethane potential (BMP) test. For the second one, wheat straw was sterilized by gamma ray radiation pretreatment and treated under different temperature with different time. Then the treated straw was used for the BMP test. The results of experiments indicated that large percentage of organic matter in wheat straw was degraded during composting process. The total solid (TS) loss rate of wheat straw was only 4.06%when composting pile temperature was less than 55℃. When composting pile temperature was set up at 55℃, the TS loss rate of wheat straw increased 22.45%after 10 days’ composting treatment. Gas data showed that biogas production rate of wheat straw was not improved obviously. The TS biogas yield of wheat straw increased with composting pile temperature and then decreased. The highest TS biogas yield of wheat straw of 349.92 mL/g was observed at 55℃of composting pile temperature, which is 7.56% higher than that of uncomposted wheat straw. There was no significantly improvement in biogas production between composted and uncomposted wheat straw during composting process for organic matter loss of wheat straw. However, longer composting time led to lower biogas yield of wheat straw. When composting pile temperature was kept at 55℃for 9 days, The TS biogas yield of composted wheat straw was only 66.58%. When the content of organic matter and material composition of wheat straw were changed, content of hemicellulose of wheat straw was decreased by 28.10%. Results of gas data of simulated composting experiment showed the same trend as the first experiment. The highest TS biogas yield of wheat straw of 342.36 mL/g was obtained at 55℃ with 8.35%, which is higher than that of control. Therefore the high temperature from composting process is an important factor of destruction of lignocellulose structure and improving biotransformation rate of wheat straw. When the composting pile temperature was set up at 55℃, anaerobic digested inoculums was added into straw pile and can be used for biogas production.

Influence of Temperature on Composition of Biogas Fermented in High-Concentrated Thermostatic Anaerobic Environment

Temperature Effects on Pig Manure under Low Level Batch Aeration

BACTERIAL RESPONSES TO TEMPERATURE DURING AERATION OF PIG SLURRY

Promotion of Biogas Production of Wheat Straw by Controling Composting Pretreatment Temperature

Effect of temperature on the persistence of fecal bacteria in ambient anaerobic digestion systems treating swine manure

Impact of Thermal Treatment on Biogas Production by Anaerobic Digestion of High-solid-content Swine Manure

Influence of Temperature on Chemical Wastewater Treatment by Two-phase Anaerobic Digestion Process

Investigation on the Interactive Effects between Temperature and Chemical Composition of Organic Wastes on Anaerobic Co-Digestion Performance

Characteristics of Biogas Production Activity and Microbial Community during Sub-Moderate Temperature Anaerobic Digestion of Wastewater

Effect of temperature and pH variation on anaerobic digestion for biogas production

Influence of temperature fluctuations on anaerobic digestion: Optimum performance is achieved at 45 °C

Effect of Temperature Variation on Codigestion of Animal Waste and Agricultural Residue for Biogas Production

Effect of temperature on microbial community of a glucose-degrading methanogenic consortium under hyperthermophilic chemostat cultivation.

The transition temperature (42 C) from mesophilic to thermophilic micro-organisms enhances biomethane potential of corn stover

Effect of bioaugmentation on gas production and microbial community during anaerobic digestion in a low-temperature fixed-bed reactor

Bioreactor Performance and Methanogenic Population Dynamics in a Low-Temperature (5–18°C) Anaerobic Fixed-Bed Reactor

Temperature Regulations Impose Positive Influence on the Biomethane Potential Versus Digesting Modes Treating Agricultural Residues.

The role of computed tomographic examination of the pelvis in the management of testicular germ cell tumours.

Understanding working conditions for Entererococcus sp. L1 on methane production: A low temperature condition-based biogas production experiment

Effects of Different Temperatures and Ph Values on Volatile Fatty Acids Production During Codigestion of Food Waste and Thermal-Hydrolysed Sewage Sludge and Subsequent Volatile Fatty Acids for Polyhydroxyalkanoates Production.

Deciphering the effects of temperature on bio-methane generation through anaerobic digestion