Abstract:Many industrial applications and experiments have shown that sliding bearings often experience fluid film whip due to nonlinear fluid film forces which can cause rotor-stator rub-impact failures. The oil-film whips have attracted many studies while the water-film whips in the water lubricated sliding bearing have been little researched with the mechanism still an open problem. The dynamic fluid film forces in a water sliding bearing are investigated numerically with rotational, whirling and squeezing motions of the journal using a nonlinear model to identify the relationships between the three motions. Rotor speed-up and slow-down experiments are then conducted with the rotor system supported by a water lubricated sliding bearing to induce the water-film whirl/whip and verify the relationship. The experimental results show that the vibrations of the journal alternated between increasing and decreasing rather than continuously increasing as the rotational speed increased to twice the first critical speed, which can be explained well by the nonlinear model. The radial growth rate of the whirl motion greatly affects the whirl frequency of the journal and is responsible for the frequency lock in the water-film whip. Further analysis shows that increasing the lubricating water flow rate changes the water-film whirl/whip characteristics, reduces the first critical speed, advances the time when significant water-film whirling motion occurs, and also increases the vibration amplitude at the bearing center which may lead to the rotor-stator rub-impact. The study gives the insight into the water-film whirl and whip in the water lubricated sliding bearing.

Oil Film Whirl Dynamic Characteristics and Influence Factors in High Speed Rotor-bearing System

Vibration Analysis of a Nonlinear Rotor-Bearing-seal System

Review of Nonlinear Rotor-Bearing Dynamics System

Modeling a Two-Span Rotor System Based on the Hamilton Principle and Rotor Dynamic Behavior Analysis

Lubrication and stability analysis of nonlinear rotor-bearing system

Study on Model of Continuous Rotor under Steam Seal Force

Nonlinear Vibration Induced by the Water-Film Whirl and Whip in a Sliding Bearing Rotor System

Nonlinear Dynamic Analysis of a Rotor/bearing/seal System

Dynamic characteristics analysis of an elliptical bearing-rotor coupled system

Dynamic Analysis of an Unsymmetrical Rotor Supported by Oil Film Bearing

Transient nonlinear dynamics of the rotor system supported by low viscosity lubricated bearing

The Nonlinear Characteristics Comparison of Rotor -bearing Under an Unsteady or Steady Oil-film Force Model

An Improved Dynamic Modelling for Exploring Ball Bearing Vibrations from Time-varying Oil Film

Investigation on the dynamic behaviors of a rod fastening rotor based on an analytical solution of the oil film force of the supporting bearing

Study on Dynamics of Micro Gas Journal Bearing--rotor System

Dynamic analysis of slant cracked rotor system considering nonlinear oil film force

On the Bifurcation and Stability of Periodic Motion of the Rotor-Bearing System with Rub-Impact and Oil Whirl

Periodic, quasi-periodic and chaotic vibrations of a rub-impact rotor system supported on oil film bearings

Nonlinear dynamic of flexible rotor supported by turbulent bearings with quadratic damping and temperature dependent viscosity

Nonlinear Dynamics of a Rub-Impact Rotor Supported by Oil Film Bearings with an Elastic Stator

Analysis of Dynamic Characteristics of Ring Squeeze Film Damper-Rotor System