Abstract:In order to study the underground coal-gasification process, Aspen Plus software was used to simulate the lignite underground gasification process, and a variety of unit operation modules were selected and combined with the kinetic equations of coal underground gasification. The model can reflect the complete gasification process of the coal underground gasifier well, and the simulation results are more in line with the experimental results of the lignite underground gasification model test. The changes in the temperature and pressure of oxygen, gasification water, spray water, and syngas in pipelines were studied, and the effects of pipe diameters on pipeline conveying performance were investigated as well. The effects of the oxygen/water ratio, processing capacity, and spray-water volume on the components of syngas and components in different reaction zones were studied. In addition, the change tendency of gasification products under different conditions was researched. The results indicate that: (1) The depth of injection and the formation pressure at that depth need to be taken into account to determine a reasonable injection pressure. (2) The liquid-water injection process should select a lower injection pressure. (3) Increasing the oxygen/water ratio favors H2 production and decreasing the oxygen/water ratio favors CH4 production. (4) The content of CO2 is the highest in the oxidation zone, the lowest in the reduction zone, and then increases a little in the methanation reaction zone for the transform reaction. The content of CO is the lowest in the oxidation zone and the highest in the reduction zone. In the methanation reaction zone, CO partially converts into H2 and CO2, and the content of CO is reduced. (5) The injection of spray water does not affect the components of the gas but will increase the water vapor content in the gas; thus, this changes the molar fraction of the wet gas.

Simulation of two-stage coal gasfication process on ASPEN PLUS

Simulation of Underground Coal-Gasification Process Using Aspen Plus

Simulation and analysis of coal based syngas methanation process based on Aspen Plus

PROCESS SIMULATION OF BIOMASS AND COAL ENTRAINED-FLOW CO-GASIFICATION BASED ON ASPEN PLUS

NUMERICAL SIMULATION OF GASIFIER IN AN IGCC DEMONSTRATION PROJECT

Comparison and Analysis of Mainstream Methanation Process of Coal-to-SNG Based on Simulation by Aspen Plus

Simulation analysis and research on coal gasification combustion

SIMULATION AND ANALYSIS ON GASIFICATION TECHNOLOGY OF A TWO-STAGE DRY FEED ENTRAINED FLOW BED

Simulation of Shell Entrained-flow Pulverized Coal Gasification Progress in Coupling with Sensible Heat Recovery

Three stage equilibrium model for coal gasification in entrained flow gasifiers based on aspen plus

Simulation of the Performance Based on ASPEN PLUS for Dry Feed Entrained Flow Coal Gasification of Entrained-Bed Gasifier

Energy and Carbon Emission Optimisation of Coal to Syngas Process

Modeling and optimization of texaco coal-water slurry gasification process

Simulation of lignite underground gasification using Aspen Plus

Simulation of biomass gasification by ASPEN PLUS

Assessment of Coal Gasification in a Pressurized Fixed Bed Gasifier Using an ASPEN Plus and Euler–Euler Model

Study on the Simulation of Source-Separated Combustible Solid Waste Fluidized Bed Gasification Based on Aspen Plus

Simulation Analysis of A Gtl Process Using Aspen Plus

Modeling of coal gasification reaction in typical entrained-flow coal gasifiers

Modeling and simulation of coal gasification with carbon dioxide reuse system

Aspen Plus Simulation of FTL Production from Coal and Biomass Gasification