Abstract:Systematic investigations of pressure drop type oscillations and their thresholds for steam-water two-phase now in a uniformly heated helical coiled tube were reported. Experiments were conducted to obtain the critical conditions far the occurrence of pressure drop type dynamic oscillation, in a closed-circulation helical coiled tubing steam generator. The study has shown that different compressible volume positions corresponding to different oscillation initial boundaries as well as different oscillating amplitude and time periods. Moving compressible volume from the inlet of steam generator to the upstream can dramatically suppress the occurrence of pressure drop oscillation. Also, non-uniform heat flux distribution along evaporating channel could change oscillating boundaries significantly, especially when higher heat flux was subjected to the higher mass quality region. A study of pressure drop oscillation in various steam generator inclinations showed that gravity has little influence upon the oscillating boundaries. Based on the experimental observations, a set of new methods was firstly proposed to eliminate the occurrence of pressure drop oscillation, The further experiments for subcooled water flow and steam-water two-phase flow were also conducted to investigate the effects of pulsation upon transient heat transfer characteristics. The non-uniform property of local heat transfer with steady flow was also examined. The secondary flow mechanism and the effect of interaction between the flow oscillation and secondary flow were analyzed on the basis of the experimental data. Some new phenomena were observed and explained. A series of correlations were proposed for the average and local heat transfer coefficients both under steady and oscillatory flow conditions. The results showed that there were considerable variations in local and peripherally time-average Nusselt numbers for pulsating flow in a wide range of parameters.

Pressure Drop Oscillation of Steam–water Two-Phase Flow in a Helically Coiled Tube

Flow instabilities and transient convective heat transfer in a helical coiled tube with pulsatile steam-water two phase flow

Experimental Investigation of Pressure Drop Oscillations of Steam Water Two Phase Flow in Helically Coiled Tubing Boiler Reactors

Transient and time-averaged oscillatory heat transfer of two-phase flow during second regional pressure-drop oscillation in helical coiled tube

An experimental investigation of oscillatory heat transfer in helical coiled tube with steam water two phase density wave oscillation flow

Transient and time averaged heat transfer characteristics of pressure drop oscillation in horizontal helically coiled tube

Transient Convective Heat Transfer in a Helical Coiled Tube with Pulsatile Fully Developed Turbulent Flow

Transient and Time-Averaged Heat Transfer of Steam Water Two-Phase Qscillatory Flow in Helical Coiled Tubing Boiler-Reactor

AN EXPERIMENTAL INVESTIGATION OF OSCILLATORY HEAT TRANSFER IN HELICAL COILED TUBE WITH STEAM WATER TWOPHASE DENSITY WAVE OSCILLATION FLOW

Experimental Investigation of Forced Convective Boiling Flow Instabilities in Horizontal Helically Coiled Tubes

Experimental investigation on the convective boiling flow instabilities of steam/water two phase flow in horizontal helically coiled tube

EXPERIMENTAL INVESTIGATION ON PRESSURE DROP OSCILLATION IN HORIZONTAL HELICALLY COILED TUBE [J]

An experimental investigation of the frictional pressure drop of steam–water two-phase flow in helical coils

Transient and Time-Averaged Boiling Heat Transfer of the Oscillatory Two-Phase Flow in Helical Coils

Convective Boiling Heat Transfer and Two-Phase Flow Characteristics Inside A Small Horizontal Helically Coiled Tubing Once-Through Steam Generator

The frictional pressure drop of steam-water two-phase flow during forced convective boiling inside a small horizontal helical coil tube

Experimental investigation of frictional resistance for steam-water two-phase flow in helical coils

Experimental Investigation of Two-Phase Flow Pressure-Drop Type Instabilities in Parallel Vertical Internally Ribbed Pipes at Low Mass Flow Rate

FRICTIONAL PRESSURE DROP CHARACTERISTICS OF STEAM-WATER TWO-PHASE FLOW IN HELICALLY COILED TUBES ORIENTED WITH VARIOUS AXIAL ANGLES

Experimental Study on Two-Phase Natural Circulation Flow Instability under Low Pressure and Low Steam Quality

Oscillation characteristics of two-phase flow in a natural circulation system with low pressure and low steam quality