Abstract:A lab-scale methanolic wastewater-fed (3000 mg COD L-1) UASB reactor was operated for 235 days to evaluate the influence of the sulfidogenesis process on metabolic routes, the re-granulation of dispersed granules and long-term process performance. Various sulfidogenesis scenarios were created by stepwise decreasing the influent COD/SO42- ratio from 20 to 0.5 at a fixed organic loading rate (OLR) of 12 g COD L-1 d-1. It was shown that the conversion of methanol to methane was stable at a wide COD/SO42- range of ≥2, attaining high biogas production rate of 3.78 ± 0.32 L L-1 d-1 with efficient concurrent removal of the total COD (96.5 ± 4.4%) and sulfate (56.3 ± 13.0%). The methane content in biogas remained relatively stable at 81.5 ± 1.6% for all COD/SO42- ratios tested. The particle size of the granules was shown to clearly increase as the COD/SO42- ratios decreased. A slight linear decline was noted in the number of electrons utilized by methane producing archaea (MPA) (from 98.5 ± 0.5% to 80.0 ± 2.4%), whereas consumption by sulfate reducing bacteria (SRB) increased (from 1.5 ± 0.5% to 20.0 ± 2.4%) with the decreasing COD/SO42- ratio. According to the results of activity tests and microbial community analysis, the conversion of methanol to methane at a low COD/SO42- ratio, except from Methanomethylovorans sp., depends not only on low levels of acetoclastic and hydrogenotrophic methanogens, but also on incomplete oxidizer SRB species (e.g. Desulfovibrio sp.) that utilize H2-CO2 with acetate to mineralize the methanol. This serves to diversify the metabolic pathway of methanol. Further analysis through scanning electron microscopy (SEM) revealed that a lower COD/SO42- ratio favored the sulfidogenesis process and diversified the microbial community inside the reactor. The benefical sulfidogenesis process subsequently invoked the formation of a sufficient, rigid [-Fe-EPS-]n network (EPS: extracellular polymeric substances), binding and immobilizing the sludge, and resulting in the re-granulation of the dispersed granules.

Study on Quick Cultivation of Granular Sludge and Its Characteristics in Methanogenic UASB

Rapid aerobic sludge granulation in an integrated oxidation ditch with two-zone clarifiers.

Cultivation of Anaerobic Granular Sludge in UASB Reactors with Aerobic Activated Sludge As Seed

Characterization of Granulation Process During UASB Start-up

Study on Simultaneous Methanogenesis and Denitrification in a UASB Reactor

Rapid cultivation of aerobic granular sludge in a pilot scale sequencing batch reactor

Cultivation of Aerobic Granular Sludge with Effluent from Anaerobic Hydrogen-producing Reactor

Characteristics of Sludge Granulation without Carrier in Full-scale UASB Reactor

Sludge Granulation in Asbr: Reactor Performance, Sludge Physiochemical Properties Evolution and the Unique Clustered Structure of the Granular Sludge

Cultivation and Granulation Process of Aerobic Granular Sludge Applied to Treat Municipal Wastewater

Characterization and Quantification of Anammox Start-Up in UASB Reactors Seeded with Conventional Activated Sludge

Cultivation of Aerobic Granular Sludge Using Municipal Wastewater and Its Degradation Characteristics

Cultivation of Aerobic Granular Sludge with A Mixed Wastewater Rich in Toxic Organics

Application of aerobic granular sludge in polishing the UASB effluent.

Research on Aerobic Granular Sludge Cultivated under Selective Pressure

Start-Up Characteristics of a Granule-Based Anammox UASB Reactor Seeded with Anaerobic Granular Sludge

Formation/characterization of humin-mediated anaerobic granular sludge and enhanced methanogenic performance

Gas-enhanced operation and stepwise organic stressing as a new alternative in realising successful sludge granulation in high-rate anaerobic bioreactor for wastewater treatment

Cultivation and Removal Efficiency of Aerobic Granular Sludge in SBAR

Sulfidogenesis process to strengthen re-granulation for biodegradation of methanolic wastewater and microorganisms evolution in an UASB reactor

Study on anaerobic granular sludge in beer waste water treatment