Abstract:A three-dimensional numerical investigation of flow boiling in mini-/micro-channels is carried out using a coupled Level-set (LS)/Volume of Fluid (VOF) method (CLSVOF) in the present study. A phase change model based on the interfacial temperature gradient is implemented and the numerical approach is first validated by the experimental and numerical results in the literature. A fabricated cavity in lieu of the traditional methods of seed bubble or local superheat is treated as the nucleation site, where boiling occurs exclusively and periodic stream of single bubble emerges. The transitions of flow patterns from bubbly flow to slug flow and annual flow are observed, and the numerical wall temperatures agree with the experimental results. The growths of the radial diameter and axial length of vapor bubble are compared with the experimental data, and good agreement is found for the radial diameter while deviation is found for the axial length due to early coalescence of bubbles near the nucleation site. Meanwhile, the local heat transfer coefficients are found to be significantly influenced by the flow patterns. The variations of the local vapor qualities at five representative locations along the flow direction are also studied quantitatively and the fluctuations are found to be consistent with the local flow patterns. Finally, we present a numerical attempt on flow boiling with two nucleation sites, which shows a good potential of the present numerical approach to deal with the complicated flow boiling process. The information presented here is very useful to the design and operation of the mini-/micro-reactors. (C) 2016 Elsevier B.V. All rights reserved.

Numerical Simulation of Micro Scale Flowing and Boiling

Simulation on Nucleate Boiling in Micro-Channel

Simulation of Subcooled Flow Boiling in a Micro-Channel

Numerical simulation of boiling behavior in vertical microchannels

Numerical simulation on flow boiling heat transfer of R32 in micro/mini-channels

A Numerical Study of Quasi-Nucleate Boiling in Mini- and Micro Channels

Bubble Dynamics of Water Boiling Heat Transfer in Vertical Rectangular Mini-Channel

3D Numerical Investigation on Flow Boiling Characteristics in Large Length-to-diameter Ratio Microchannel

3-D numerical study of subcooled flow boiling in a horizontal rectangular mini-channel by VOSET

Three Dimensional Numerical Simulation on Bubble Growth and Merger in Microchannel Boiling Flow

Numerical Simulation of Bubble Growth and Heat Transfer During Flow Boiling in a Surface-Modified Microchannel

Evolution of Flow Patterns and the Associated Heat and Mass Transfer Characteristics During Flow Boiling in Mini-/Micro-channels

Numerical Simulation of Boiling Heat Transfer of Water in Vertical Rectangular Mini-Channels

Experimental and Numerical Studies on Enhanced Flow Boiling in Tube with Superwetting Micro-Finned Surfaces

Bubble behavior in microchannel with saturated and subcooled boiling

Experimental and Numerical Study of Flow Boiling in a Vertical Upward Narrow Rectangular Channel under Low Heat Flux

Numerical simulation of subcooled boiling considering bubble sliding behavior in conventional channels

Three-dimensional numerical simulation of saturated annular flow boiling in a narrow rectangular microchannel

Numerical investigation of saturated flow boiling in microchannels by the lattice boltzmann method

Flow pattern of boiling in micro-channel by numerical simulation

Numerical Simulation of Single Bubble Growth in Vertical Rectangular Narrow Flow Channels