Abstract:Slightly acidic electrolyzed water (SAEW) with pH 5.0-6.5 is produced by electrolysis of dilute hydrochloric acid or salt solution in a chamber without a membrane. SAEW can effectively kill various pathogenic bacteria as one of the most potential green disinfectants. However, SAEW is susceptible to being exposed to time, air, and illumination etc. The influence of SAEW for inactivation ofEscherichia coli on white shrimp (Litopenaeus vannamei) under different washing conditions was investigated. At room temperature, the effectiveness of SAEW (with available chlorine concentration (ACC) of 20 mg/L, pH value of 6.1 and ORP of 812 mV) to inactivate Escherichia coli with different dipping times (2, 5 and 10 min), weight ratio of shrimp to SAEW (1:4, 1:10 and 1:20) was evaluated, and changes of ACC were also measured. For inoculation, each shrimp was determined to be intact, and then exposed to a 90°C water bath boiling for 20 min. to inactivate bacteria on the surface of shrimps. Each sample was inoculated with E. coli by spreading 0.5 mL onto each surface respectively and then placed in a clean bench for 20 min. to allow for the attached E. coli. The level of E. coli on the shrimp surface was ensured to be of approximately 6.0-7.0 lgCFU/mL, and bacterial cells on surfaces of shrimp or in residual solution after treatment were counted using a dilution plate count at 37°C for 24h onto nutrient agar, and shrimp that were not washed were used as a control. Moreover, the decay kinetics models of ACC in SAEW during disinfection were established. The effect of SAEW on meat quality was also evaluated, respectively from color, pH value, hardness, and the moisture distribution. The results showed that SAEW has a strong bactericidal activity againstE coli. on white shrimp, while distilled water has a relative weaker role. As the action time prolonged, and the amount of SAEW increased, the bactericidal effect of SAEW was intensified. Meanwhile, the residue bacteria colony in SAEW was also reduced and expenses of active chlorine was increased as the action time was prolonged, and the amount of SAEW increased during the disinfection process. The effective order of time on the bactericidal activity of SAEW was 10 min > 5 min > 2 min under the same ratio of shrimp to SAEW, dipping in SAEW (weight ratio of shrimp to SAEW was 1:4) for 10 min reducedE. coli population from 6.6 to 3.9 lgCFU/mL, which better than the control treatment. E.coli counts in a residual solution can reduce by 1-2 lgCFU/mL. Increasing the amount of SAEW enhanced the bactericidal effect obviously. The decay of ACC and bactericidal kinetic followed first-order kinetics during the disinfection process, and the model had good predicted results. In addition, there was no significant differences between the treated meat quality by SAEW and the controls, respectively from color, pH, hardness, and the moisture distribution of white shrimp meat. Therefore, SAEW has a strong bactericidal activity, and does not affect the meat quality of white shrimp, and has a great potential for application compared with the traditional thermal treatment.

Inactivation and Disinfection Kinetics of Salmonella sp.and E.coli in Egg White Exposed to Dense Phase Carbon Dioxide

Effect of High Pressure on Inactivation of Escherichia Coli in Frozen Suspension

Kinetics of Escherichia Coli Inactivation in Frozen Aqueous Suspensions by High Pressure and Its Application to Frozen Chicken Meat

The Destruction and Sublethal Effect of Cycle or Continuous High Pressure Treatment on Escherichia Coli in Different Frozen and Unfrozen Media

Effect of combined electrolyzed reduced water and slightly acidic electrolyzed water spraying on the control of Salmonella, eggshell quality, and shelf life of eggs during storage

Escherichia Coli Inactivation in Water Using Pulsed Discharge

Demonstration of Escherichia Coli Inactivation in Sterile Physiological Saline under High Pressure (HP) Phase Transition Conditions and Analysis of Probable Contribution of HP Metastable Positions Using Model Solutions and Apple Juice

Frozen-Phase High-Pressure Destruction Kinetics of Escherichia Coli As Influenced by Application Mode, Substrate, and Enrichment Medium

Effect of Slightly Acidic Electrolyzed Water for Inactivation of Escherichia Coli on White Shrimp (litopenaeus Vannamei )

Inactivation Mechanism of Escherichia Coli Induced by Slightly Acidic Electrolyzed Water.

Disinfection effect and kinetics of slightly acidic electrolyzed water for white shrimp

High-pressure Inactivation Kinetics of Staphlococcus Aureus in Chinese Soybean Paste

Regulation of the Ice Ⅰ to Ice III High Pressure Phase Transition Meta-Stability in Milk and Its Bactericidal Effects

Effect of Low-Temperature-High-Pressure Treatment on the Reduction of <i>Escherichia coli</i> in Milk

Inactivation effect and kinetics of cathepsin L from white shrimp (Litopenaeus vannamei) by dense phase carbon dioxide

Egg-White Proteins Have a Minor Impact on the Bactericidal Action of Egg White Toward Salmonella Enteritidis at 45°C

The effect of dense phase carbon dioxide on the conformation of hemoglobin

Investigation of Campylobacter contamination in poultry meat and its inactivation kinetics characteristics during cold storage

The Inactivation of Escherichia Coli with Dielectric Barrier Discharge in Water-Air Mixture

Efficacy of pectin-based caproic acid, caprylic acid, linalool, and cuminaldehyde coatings in reducing Salmonella Heidelberg on chicken eggs