Abstract:This study investigated biological treatment for two kinds of volatile organic compounds (VOCs)-containing wastewaters collected from wet scrubbers in a semiconductor industry. Batch test results indicated that one wastewater containing highly volatile organic compounds was not suitable for aerated treatment conditions while the other containing much lower volatile organic compounds was suitable for aerobic treatment. Accordingly, two moving bed bioreactors, by adding commercial biocarrier BioNET, were operated under aerobic and anoxic conditions for treating low volatility wastewater (LVW) and high volatility wastewater (HVW), respectively. During 280 days of operation, the aerobic LVW bioreactor attained the highest chemical oxygen demand (COD) removal rate of 98.9 mg-COD/L/h with 81% of COD removal efficiency at hydraulic retention time (HRT) of 1 day. The anoxic HVW bioreactor performed above 80% of COD removal efficiency with the highest COD removal rate of 16.5 mg-COD/L/h at HRT of 2 days after 380 days of operation. The specific COD removal rates at different initial substrate-to-biomass (S0/X0) ratios, using either suspended sludge or microorganisms attached onto BioNET from both bioreactors, followed the Monod-type kinetics, while the half-saturation coefficients were generally higher for the microorganisms onto BioNET due presumably to relatively poor mass transfer efficiency. Based on the results of microbial community analysis using the next generation sequencing technique, the dominant communities of suspended sludge and BioNET, including nitrifiers, denitrifiers, and degraders for polycyclic aromatic hydrocarbons, were similar in the corresponded bioreactors, but microbial community shifts were observed with increased organic loadings.

Enhancement of biodegradability of municipal wastewater consisting mainly of dyeing and printing wastewater by hydrolysis upflow sludge bed

Pretreatment of a textile wastewater from alkali reduction,printing and dyeing operations

Combined photocatalytic pre-oxidation reactor and sequencing batch bioreactor for advanced treatment of industrial wastewater

Preliminary Study on Treatment of Dye Producing Wastewater with Upflow Anaerobic Sludge Blanket

Novel Quantitative Evaluation of Biotreatment Suitability of Wastewater

Study on treatment of dyeing wastewater by combined process of biological micro-electrolysis

Hydrothermal Pretreatment Technology of Municipal Biomass Waste

Study on Biodegradability and Biotoxicity of Pharmaceutical Wastewater

Effect of Circulation Rates on Performance of UASB Reactor Treating the Wastewater Containing Nondegradable Substrate from Chemical Industrial

A synergistic approach combining computational fluid dynamics simulation with hydrolysis-acidification for dye wastewater treatment

DEGRADATION OF LOW CONCENTRATION DI-N-BUTYL PHTHALATE IN THE TAIL WATER OF MUNICIPAL SEWAGE PLANT BY UV/H2O2

Research about Organic Matter Removal and Biofilms Development of Pilot-Scale UV/H2O2-BAC Process

Insight into the application of micro-nano bubbles combined with heat-activated persulfate oxidation for removing dissolved organic matter from printing and dying wastewater

Biological Treatment Of Dye Wastewaters Using An Anaerobic-Oxic System

Food wastewater treatment using a hybrid biofilm reactor: nutrient removal performance and functional microorganisms on filler biofilm and suspended sludge

Study on Treatment of the Real Silk Print and Dyeing Wastewater with the Anaerobic Biotechnology under Ambient Temperature

Biological treatment of volatile organic compounds (VOCs)-containing wastewaters from wet scrubbers in semiconductor industry

Degradation of Dye Wastewater by a Novel mBT-MPR Visible Light Photocatalytic System

Wastewater treatment by alkali bacteria and dynamics of microbial communities in two bioreactors

Pilot-scale study on nitrogen and aromatic compounds removal in printing and dyeing wastewater by reinforced hydrolysis-denitrification coupling process and its microbial community analysis

Improving Biodegradation Potential of Domestic Wastewater by Manipulating the Size Distribution of Organic Matter.