Abstract:Adding limestone to coal combustion reduces SO2 emissions but sometimes increases NO emissions, posing a challenge for synergistic SO2 and NO control in circulating fluidized bed (CFB) boilers. Limestone in the CFB furnace can participate in the conversion of sulfur and nitrogen compounds from coal and its devolatilized coke. This study compared the effects of limestone on SO2 and NO emission characteristics during coal/coke combustion to explore the potential for controlling both emissions. Combustion experiments were conducted in a fixed-bed reactor under different reaction parameters including Ca/S mole ratio, oxygen concentration, and temperature. Results showed that SO2 emissions decreased and NO emissions increased with increasing Ca/S mole ratio for both fuels. Comparing the emissions from fuels with and without limestone addition, a lower oxygen concentration decreased the desulfurization efficiency and the increment of NO emissions caused by limestone for both fuels. Temperature had opposite effects of limestone on coal or coke combustion. For coke, higher temperatures improved desulfurization efficiency and decreased the increment of NO emissions caused by limestone. For coal, the effects were reversed. To explain the impact of temperature, the sulfur and nitrogen migration paths affected by limestone were analyzed based on the XPS results of the fuels. Thiophene-S and N-Q became the main sulfur and nitrogen components in coke at high temperatures. The conversion of thiophene-S into SO2 is slow, and the limestone is calcined more fully during coke combustion, improving the utilization rate of limestone. N-Q tends to be converted into NH3. Further, NO is reduced by NH3 over the catalyze of CaO at low oxygen conditions. This reaction process decreases the increment of NO emissions caused by limestone.

Effect of Controlled Oxidation on Wet FGD Process

Investigation of the Kinetics of Sulfite Oxidation on by-Production Recovery Process in WFGD

Experimental Study of Desulfurization Process with Limestone Slurry Enhanced by Hexanedioic Acid

Experimental Investigation on Disposal of the Product from a Slurry Jet WFGD

REACTION RATE OF SULFITE OXIDATION WITHOUT CATALYST

Mass Transfer and Kinetics Study on the Sulfite Forced Oxidation with Manganese Ion Catalyst

Study on Fine Particles Influence on Sodium Sulfite and Oxygen Gas-Liquid Reaction

Nitrogen Oxide Absorption and Nitrite/nitrate Formation in Limestone Slurry for WFGD System

STUDY ON DESULFURIZATION CHARACTERISTIC IN CaO ACTIVATION REACTOR OF LIMESTONE INJECTION FGD SYSTEM --EXPERIMENTAL RESULTS AND DISCUSSION

Simultaneous Absorption of NOx and SO2 in Oxidant‐enhanced Limestone Slurry

Comprehensive Effect of Oxidant Addition in an FGD Slurry on the Removal and Distribution of Selenium: A Field Study.

Oxidation Inhibition of Sulfite in Dual Alkali Flue Gas Desulfurization System.

Catalytic Oxidation of Calcium Sulfite in Solution/aqueous Slurry.

Kinetics and Mechanism of Sulfite Oxidation in the Magnesium-Based Wet Flue Gas Desulfurization Process

Enhancement of citric acid on low-grade limestone wet desulfurization performance coupled with spray and partial bubble technology

ORP as slurry oxidation index and model modification in wet desulfurization system

Study on Advanced Treatment of Coking Wastewater by Fenton Oxidation Process

Experimental study on the effect of limestone on SO2 and NO emission characteristics during coal/coke combustion

Effects of high steam partial pressure on desulfurization process of limestone

Experimental study on SO2 absorption rate enhanced by additive in limestone-gypsum WFGD process

Effect of Flow Rate and Partial Pressure of Oxygen on Desulfurization of KR Slag