Abstract:Solution processing techniques are often used to enhance intra and interchain order in semiconducting conjugated polymer thin films used in the active layer of organic optoelectronic devices. While there has been extensive research into the impact of solution processing on the local structural and electronic properties of these films, the nanomechanical properties of the films are less well understood and are challenging to characterize. We investigate the nanomechanical properties of conjugated polymer thin films arising from solution processing techniques. Our study relies on dynamic secondary solvent dripping to induce subtle changes to the film morphology. We examine thin films of P3HT, PCDTBT, PTB7, and PBDB-T-SF conjugated polymers, commonly used in organic photovoltaics, with the bimodal amplitude-frequency-modulation (AM-FM) imaging mode of atomic force microscopy (AFM) viscoelastic method to probe their local physical and mechanical properties. We find that Young's Modulus data measured by AM-FM AFM can detect additional changes in film properties not detectable by other commonly used characterization techniques (UV–visible absorption spectroscopy, X-ray diffraction, nanoindentation). We detected an increase in molecular order for PBDB-T-SF that is not detected by UV–visible absorption spectroscopy, X-ray diffraction or nanoindentation. PCDTBT, the most amorphous of the polymers studied, showed no changes in absorption or X-ray diffraction data, yet clear changes in Young's Modulus were detected by AFM. On the other hand, increases in P3HT order that occurred due to dynamic secondary solvent dripping are detected in both the bulk and AFM measurements. Our study demonstrates the applicability of nanomechanical measurements for characterizing local structural variations in conjugated polymer films. This work is relevant to ongoing efforts to control and understand the complex structure-property-processing relationships of conjugated polymers thin films.

Atomic Force Microscopic (AFM) Study on a Self-Organizing Polymer Film

Ordered Self-Organizing Films of an Amphiphilic Polymer by Slow Evaporation of Organic Solvents

Observation of elongated and aligned polymer chains in a two-dimensional system by atomic force microscopy

Nanomechanics of Polyphenylacetylene Derivatives by AFM-based SMFS

Polymer-Chain Structure of Polyimide Langmuir-Blodgett-Films Determined by Atomic-Force Microscopy

Crystallization morphology and self-assembly of polyacrylamide solutions during evaporation

Atomic force microscopy studies of rubbed polyimide films

Self-assembling structures and thin-film microscopic morphologies of amphiphilic rod-coil block oligomers.

In Situ Real-Time Atomic Force Microscopy Observations of Chain Mobility at Polymer/Water Interfaces of Poly(methyl methacrylate), Poly(2-hydroxyethyl methacrylate), and Poly(2-methoxyethyl methacrylate) Films in Water

A new kind of ultrathin film—The assembly of amphiphilic polymer

Real‐time AFM Study of Lamellar Growth of Semi‐crystalline Polymers

Characterization of nanoscale morphology and mechanical properties of conjugated polymer thin films dynamically exposed to a secondary solvent

Fabrication And Afm/Ffm Studies Of C-60-Containing Polyelectrolyte Self-Assembled Films

Direct Imaging of Interfacial Fluctuations in Confined Block Copolymer with in Situ Slow-Scan-Disabled Atomic Force Microscopy

Self-assembly behavior of fluorinated amphiphilic copolymer in aqueous solution and its properties in the solid film state

Atomic Force Microscopy Studies of Domain Structures in Phase-Separated Monolayers

Novel Microstructures Prepared by the Mixed Langmuir-Blodgett Technique and Identified by Atomic Force Microscopy

System of Macromolecular Self-Assembly and Its Structural Characterization

Surface Nanopatterning Using the Self-Assembly of Linear Polymers on Surfaces after Solvent Evaporation

Evaporation Induced Crystal Nucleation and Morphology of Dried Poly (Vinylidene Fluoride) Droplets

Extracting a Single Polyethylene Oxide Chain from a Single Crystal by a Combination of Atomic Force Microscopy Imaging and Single-Molecule Force Spectroscopy: Toward the Investigation of Molecular Interactions in Their Condensed States.