Abstract:The aim of this study is to determine design and process parameters of the aerobic granular sludge system to treat actual domestic wastewater. The aerobic granular sludge was developed in a 2.5 L lab-scale bioreactor which uses the operational system based on the sequencing batch reactor (SBR). The bioreactor was fed with influent from local sewerage treatment plant and seeding with fresh inoculums (seed sludge) from activated sludge tank. The operation of the reactor was based on the SBR system with a complete cycle time of 4 hours and specifically designed to be operated for 24 hours continuously. Two sets of experiments were carried out in a single-walled cylindrical glass column bioreactor. These two sets of experiments are referred to as SBR A and SBR B with different time setting. SBR systems have four stages which is feeding, aeration, settling and decant. It was carried out in sequence: (1) 'feeding with aeration' for SBR A (feed and aerate pumps operated simultaneously); 'feeding without aeration' for SBR B (feed and aerate pumps operated separately), (2) 'aeration only', (3) 'settling', and (4) 'discharge'. Removal performance of the SBR such as BOD, COD, AMN, NO3 − , TSS, VSS and TP along with the other several parameters of the SBR such as DO, SOUR, ORP and settling profile are monitored daily. Starting from day 1 until day 26 the average DO values were around 1 - 2 mg/l but after 1.5 hours the DO values increased drastically. It shows that the microbe did not consumed air during the process. Day 13 onwards SOUR profiles show that the microbe consumed oxygen slowly. These results suggest that low amount of readily oxidized organic available in the bioreactor. The SVI reading shows good settling performance which is less than 100 mL/g. The settling profile shows the sludge has been further compact day by day. From the finding, it is suggested that it would be better for feed and aerate pumps to be operated separately.

Pilot test of domestic wastewater treatment in anaerobic/aerobic granular sludge SBR system

A Case for Aerobic Sludge Granulation: from Pilot to Full Scale

Formation of Aerobic Granular in Pilot-scale SBR for Real Wastewater Treatment

Cultivation and Granulation Process of Aerobic Granular Sludge Applied to Treat Municipal Wastewater

Simultaneous Phosphorus and Nitrogen Removal of Domestic Sewage with Aerobic Granular Sludge SBR

Granulation of Activated Sludge in A Pilot-Scale Sequencing Batch Reactor for the Treatment of Low-Strength Municipal Wastewater

Pilot study on treatment of low concentration municipal sewage by continuous flow aerobic granular sludge technology

[Cultivation of aerobic granules in a large pilot SBR with domestic sewage]

TREATMENT OF MUNICIPAL DOMESTIC SEWAGE WITH AEROBIC GRANULAR SLUDGE

Cultivation of Aerobic Granular Sludge Using Municipal Wastewater and Its Degradation Characteristics

Cultivation and Removal Efficiency of Aerobic Granular Sludge in SBR

The treatment of solvent recovery raffinate by aerobic granular sludge in a pilot-scale sequencing batch reactor

Advanced nitrogen and phosphorus removal in pilot-scale anaerobic/aerobic/anoxic system for municipal wastewater in Northern China

Cultivation of the Aerobic Granular Sludge in Sequencing Batch Reactor

Sludge granulation and performance of a low superficial gas velocity sequencing batch reactor (SBR) in the treatment of prepared sanitary wastewater.

Aerobic Granulation SBR in Treating Effluent from UASB

Study on Physicochemical Characteristics of Aerobic Granular Sludge Cultivated in SBR

Enhancement of start-up of pilot-scale granular SBR fed with real wastewater

[Cultivation of Aerobic Granular Sludge for Simultaneous Nitrification and Denitrification in SBR System].

To Optimize Sequencing Batch Reactor (SBR) and Monitor Aerobic Granular Sludge (AGS) Development for Domestic Wastewater Treatment