Abstract:Lignin degradation restricts corn stover anaerobic fermentation efficiency. The vacuum negative pressure aerobic hydrolysis pretreatment of corn stover was tested, and the optimal combined pretreatment conditions were presented in this paper. Because of the physical characteristics of light weight and large specific porosity of stover, it led to the formation of a scum layer during the fermentation process and thus reduced the gas production rate. In the pretreatment design, the vacuum conditions (0.02-0.08 MPa) and dwell time (5-20 min) were selected to see the changes of volumetric weight, swelling and specific porosity of corn stover, resulting in an increase of the volumetric weight by 7.18%-28.72%, an increase of the swelling by 3.18%-58.59%, and a decrease of the specific porosity by 9.34%-38.59%, as compared with the CK group. Continuous vacuum negative pressure treatment could discharge the air inside the stover destroy the microstructure, and cause the stover to settle more easily during the aerobic hydrolysis process. The optimal aerobic hydrolysis temperature and time were determined to be 39 degrees C and 12.65 h, respectively. With the optimal pretreatment, the corn stover anaerobic fermentation test realized a cumulative methane yield of 260.44 mL/g VS, 22.71% higher than CK group; meanwhile, the hydraulic retention time was shortened 32.39%.

Study on Vacuum Recovery Method Eliminate Fermentation Alcohol on Barm Late Inhibition

Concentration of Lignocellulosichydrolyzates and Removal of Furfural by Vacuum Membrane Distillation

Simultaneous Concentration and Detoxification of Lignocellulosic Hydrolyzates by Vacuum Membrane Distillation Coupled with Adsorption.

Effects of components in lignocellulosic ethanol fermentation broth on ethanol transfer through polydimethylsiloxane-silicalite-1 pervaporation membrane

Optimizing Techniques for Preparation of Alcohol Fuel from Raw Potatoes Flour by Simultaneous Saccharification and Fermentation

Ethanol production from food waste at high solids content with vacuum recovery technology.

Study of Ethanol Fermentation Using Vacuum-Cell Recycle

Application of silicon rubber pervaporation membrane to butanol fermentation

Study on Production of Fermentation Ethanol by a Not Steamed Method Using Alcohol Distillation Slurry

Impact of Accumulated By-products During Distillage Recycling on Growth and Ethanol Fermentation of the Self-flocculating Yeast SPSC01

Preparation of fuel alcohol by low-temperature hydrolysis of raw cassava meal

Pretreatment Technology for Ethanol Fermentation Broth from Food Waste

Treatment of Thin Stillage by Aspergillus Oryzae and Its Effect on Alcoholic Fermentation in Syrup Liquid

Study on the Process of Fed-Batch Very High Gravity Ethanol Fermentation with Massive Inocula

Effect of Vacuum Negative Pressure Aerobic Hydrolysis Pretreatment on Corn Stover Anaerobic Fermentation

Study of Cyclic Fermentation Process of Water-saving

Study on the Fermentation Technology of High-efficiency Environment-protection and Energy-saving Alcohol

Pretreatment Technology for Suspended Solids and Oil Removal in an Ethanol Fermentation Broth from Food Waste Separated by Pervaporation Process

[Process Development for Continuous Ethanol Fermentation by the Flocculating Yeast under Stillage Backset Conditions].

Study on the saccharification and alcoholization of vinegar production raw material

Research on the Recycling of Distillation Waste in Ethanol Fermentation from Food Waste and Its Influence