Abstract:Starting from analysis to Yang's formula for type A choking, a unified and self-consistent model for fast fluidization dynamics, named the separate-phase-coexistence model, was proposed in this paper. The basic assumptions used in the model are that all the gas from outside enters the solid-saturated upward dilute phase, to which the Yang's formula is still applied, yet revised with an effective velocity factor F(β); while the clusters fall down freely at a velocity consistent with their voidage. The impact of falling clusters on the upward dilute phase was considered with the equivalent wall friction, from which the method to predict the apparent solids holdup of upper dilute region was obtained. The force balance for falling clusters was also analyzed, from which the cluster voidage was determined. When the cluster viodage reaches its minimum value, a small part of outside gas will invade the cluster, resulting in the so-called “secondary fluidization of clusters”. It well predicted that the solids holdups of upper dilute region and bottom dense region did not change obviously with further increase of the solid circulation rate, the most impressive feature of high-density fast beds. Furthermore, by analogy to bubbling beds, the phenomena of clusters in risers of fast beds were analyzed in a meso-scale mechanism, from which the effective velocity factors of dilute phase F(β) were theoretically determined. And the solid-wall friction factors in Yang's formula and the Harris's correlation for cluster size were also reconstructed based on the experimental data available in the literatures. Without any model parameters adjusted, the unified model predicted successfully the type C choking, the solids holdups for both upper dilute region and bottom dense region, and the transitions to high-density fast bed and dense suspension up-flow. The predictions were compared with several hundreds of experimental data available in the literatures, which verified well the model's unification and acceptable accuracy.

A Unified Model for Fast Fluidization Dynamics-Part Ⅲ: Prediction of High-Density Fast-Fluidized Bed

A unified model for fast fluidization dynamics-part III: prediction of high-density fast-fluidized bed

CFD Simulation of an Agitated Gas-Fluidized Bed: Effects of Particle–particle Restitution Coefficient on the Hydrodynamics

Research Progress in Numerical Models on Gas-Solid Fluidization of Cohesive Particles

Experimental and numerical investigation of solid behavior in a gas–solid turbulent fluidized bed

A unified model for fast fluidization dynamics - Part II: Prediction of upside dilute phase holdup and lower dense phase holdup

Evolution and Fluidization Behaviors of Wet Agglomerates Based on Formation-Fragmentation Competition Mechanism

Particle Fluidization Characteristics and Transition in a Hot Gas-Solid Fluidized Bed with Liquid Injection

Experimental and Modeling Investigation of Liquid-Induced Agglomeration in a Gas–Solid Fluidized Bed with Liquid Spray

A Volatile Spray Zone Model and Experimentation in a Gas-Solid Fluidized Bed with Liquid Injection

A Type-A-Choking-Oriented Unified Model for Fast Fluidization Dynamics

Effect of Bed Thickness on a Pseudo 2D Gas-Solid Fluidized Bed Turbulent Flow Structures and Dynamics

Mesoscale Analysis on Clusters in Conjunction with Fast Fluidized Bed Modeling

Modeling of the Minimum Fluidization Velocity and the Incipient Fluidization Pressure Drop in a Conical Fluidized Bed with Negative Pressure

Update and Extension of the Mesoscale Model for Fast Fluidization: Toward Type C Choking, High-Density Fast-Bed, and Flow-Regime Map

Multi-scale simulation of particle density effects on hydrodynamics in dense gas-solid fluidized beds

A Computational Particle Fluid-Dynamics Simulation of Hydrodynamics in a Three-Dimensional Full-Loop Circulating Fluidized Bed: Effects of Particle-Size Distribution

Two-Fluid Simulation of a Three-Dimensional Spout-Fluid Bed: Flow Structures, Regimes, and Insight into the Mechanism of Particle–Particle Momentum Transfer

Solid particle convection models in the dense phase of fluidized bed

A Euler-Euler Hydrodynamic Modelling and Simulation of Dense Particle Flow in a Small-Scale Fluidized Bed

Improved Model of Dense Gas-Particle Two-Phase Flow