Abstract:Coagulation plays an important role in effectively alleviating ultrafiltration (UF) membrane fouling due to the existence of flocs. In comparison to traditional filtration, direct filtration (no sedimentation tank) is generally considered to result in less membrane fouling due to the looser cake layer formed on the membrane surface. However, cake layer characteristics are easily influenced by operating conditions (e.g., sedimentation time, temperature), resulting in different fouling loads and the still very limited knowledge about the fouling behavior. Here, a detailed investigation of UF membrane performance was carried out to analyze the differences between traditional filtration and direct filtration. The results showed that a critical settling time indeed existed when flocs gradually settled, leading to severe membrane fouling induced by a dense and thick cake layer. Therefore, the traditional filtration performed worse when the settling time was shorter than the critical time, while it performed better when the settling time was longer. In comparison to room temperature water, the proportion of membrane fouling caused by the cake layer increased at low water temperature due to the contracted membrane pore size, and the cake layer thickness became the main fouling load. The longer the settling time, the fewer pollutants reached the membrane surface, the thinner the cake layer, and the lower the potential for membrane fouling. Thus, traditional filtration performed better than direct filtration, and the critical settling time was not obvious. Although solution pH played an important role in floc properties, the fouling load was influenced little and traditional filtration still performed better. This work shows that the cake layer properties/fouling loads vary with the settling time during the coagulation-UF process, and this finding is of great significance to the improvement of membrane technology in drinking water plants.

Effect of Ph on UF Membrane Fouling

Effect of Coagulation Pretreatment on the Fouling of Ultrafiltration Membrane

Effects of Coagulation on Submerged Ultrafiltration Membrane Fouling Caused by Particles and Natural Organic Matter (NOM)

Effect of Ph on Performance of Ultrafiltration

Influence of Coagulation Pretreatment on UF Membrane Flux

Characterization of Fouling in Immersed Polyvinylidene Fluoride Hollow Fibre Membrane Ultrafiltration by Particles and Natural Organic Matter

Effects of membrane material and pretreatment coagulation on membrane fouling: fouling mechanism and NOM removal

Ultrafiltration and Nanofiltration Membrane Fouling by Natural Organic Matter: Mechanisms and Mitigation by Pre-Ozonation and Ph.

Contribution of Fe3O4 Nanoparticles to the Fouling of Ultrafiltration with Coagulation Pre-Treatment.

Influence of Calcium Ion on Membrane Fouling during Ultrafiltration of Natural Organic Matter

[Effect of Charged Ultrafiltration Membrane on Natural Organic Matter Removal and Membrane Fouling].

Effect of Low Dosage of Coagulant on the Ultrafiltration Membrane Performance in Feedwater Treatment

Comparison of FeCl3 and Alum Pre-Treatment on UF Membrane Fouling

Combined effects of coagulation and adsorption on ultrafiltration membrane fouling control and subsequent disinfection in drinking water treatment

Effect of Different Cations on UF Membrane Fouling by NOM Fractions

Impacts of Natural Organic Matter Adhesion on Irreversible Membrane Fouling During Surface Water Treatment Using Ultrafiltration

Influence of Sedimentation with Pre-Coagulation on Ultrafiltration Membrane Fouling Performance.

[Effect of Coagulation on Preventing Membrane from Fouling].

Membrane Fouling in an Integrated Adsorption–uf System: Effects of NOM and Adsorbent Properties

Combined Effects of Pac Adsorption and in Situ Chlorination on Membrane Fouling in A Pilot-Scale Coagulation and Ultrafiltration Process

Effects of pre-ozonation on the ultrafiltration of different natural organic matter (NOM) fractions: Membrane fouling mitigation, prediction and mechanism