Abstract:Human being faces two key problems: world-wide energy shortage and global climate worming. To reduce energy consumption and carbon emission, it needs to develop high efficiency heat transfer devices. In view of the fact that the existing enhanced technologies are mostly developed according to the experiences on the one hand, and the heat transfer enhancement is normally accompanied by large additional pumping power induced by flow resistances on the other hand, in this chapter, the field synergy principle for convective heat transfer optimization is presented based on the revisit of physical mechanism of convective heat transfer. This principle indicates that the improvement of the synergy of velocity and temperature gradient fields will raise the convective heat transfer rate under the same other conditions. To describe the degree of the synergy between velocity and temperature gradient fields a non-dimensional parameter, named as synergy number, is defined, which represents the thermal performance of convective heat transfer. In order to explore the physical essence of the field synergy principle a new quantity of entransy is introduced, which describes the heat transfer ability of a body and dissipates during hear transfer. Since the entransy dissipation is the measure of the irreversibility of heat transfer process for the purpose of object heating the extremum entransy dissipation (EED) principle for heat transfer optimization is proposed, which states: for the prescribed heat flux boundary conditions, the least entransy dissipation rate in the domain leads to the minimum boundary temperature difference, or the largest entransy dissipation rate leads to the maximum heat flux with a prescribed boundary temperature difference. For volume-to-point problem optimization, the results indicate that the optimal distribution of thermal conductivity according to the EED principle leads to the lowest average domain temperature, which is lower than that with the minimum entropy generation (MEG) as the optimization criterion. This indicates that the EED principle is more preferable than the MEG principle for heat conduction optimization with the purpose of the domain temperature reduction. For convective heat transfer optimization, the field synergy equations for both laminar and turbulent convective heat transfer are derived by variational analysis for a given viscous dissipation (pumping power). The optimal flow fields for several tube flows were obtained by solving the field synergy equation. Consequently, some enhanced tubes, such as, alternation elliptical axis tube, discrete double inclined ribs tube, are developed, which may generate a velocity field close to the optimal one. Experimental and numerical studies of heat transfer performances for such enhanced tubes show that they have high heat transfer rate with low increased flow resistance. Finally, both the field synergy principle and the EED principle are extended to be applied for the heat exchanger optimization and mass convection optimization.

A Novel Method to Improve the Performance of Heat Exchanger??temperature Fields Coordination of Fluids

Improvement of Thermal Performance of Novel Heat Exchanger with Latent Heat Storage

Analytical and Numerical Study on the Uniformity of Temperature Difference Field in Heat Exchangers

An experimental study of the influence of the temperature difference field uniformity on cross-flow heat exchanger performance

Passage arrangement design for multi-stream plate-fin heat exchanger under multiple operating conditions

Analysis and optimization of heat transfer performance of multi-stage tower-type direct contact heat exchangers in waste heat recovery

Numerical Analysis of Header Structure Improvement in a Plate-Fin Heat Exchanger

Improvement of heat exchanger efficiency by using hydraulic and thermal entrance regions

Enhancing heat transfer efficiency in corrugated tube heat exchangers: A comprehensive approach through structural optimization and field synergy analysis

Optimization Principles For Heat Convection

Field Synergy Analysis of the Dynamic Process of a Multi-stream Heat Exchanger

A Novel Optimization Framework for Designing Multi-Stream Compact Heat Exchangers and Associated Network

Configuration optimization of shell-and-tube heat exchangers with helical baffles using multi-objective genetic algorithm based on fluid-structure interaction

Fluid Flow Distribution and Heat Transfer in Plate-Fin Heat Exchangers

Fluid-structure interaction analysis of heat exchanger with torsional flow in the shell side

Differences and Relations of Objectives, Constraints, and Decision Parameters in the Optimization of Individual Heat Exchangers and Thermal Systems

Experimental investigation on combined flow and temperature non-uniformity for three-fluid compact heat exchanger with cross flow configuration

Three-dimensional numerical study of heat transfer characteristics of plain plate fin-and-tube heat exchangers from view point of field synergy principle

A Thermal Design Method for the Performance Optimization of Multi-Stream Plate-Fin Heat Exchangers

Heat transfer characteristics and optimization strategies in supercritical fluid heat exchangers with non-uniform thermal boundaries: A systematic review

A Target-Evaluation Method for Heat Exchanger Network Optimisation with Heat Transfer Enhancement