Abstract:Most of the existing studies on acid corrosion of concrete have focused on the mechanical behavior of concrete structures under monotonic load or without load. To investigate the mechanical properties of in-service concrete components under cyclic load in an acid corrosion environment, six groups of concrete prism specimens with different acid corrosion degrees (corrosion duration) were designed and prepared by the accelerated corrosion test method. The monotonic and cyclic axial compression load tests on these specimens were conducted to investigate the effects of corrosion degree on the mechanical properties of concrete specimens. The experimental results indicated that hydrochloric acid corrosion has obvious effects on the failure characteristics and mechanical properties of concrete. The surface of corroded concrete was easier to crack and spall under load, and the concrete spalling area enlarged as the acid corrosion duration increased. The compressive capacity of concrete specimens reduced rapidly with the increase in corrosion duration. The stress–strain envelope curves for concrete with different corrosion duration under cyclic load were essentially similar to that of concrete under monotonic load. The degradation rate of the descending section for the stress–strain curves of corroded concrete under cyclic load was much larger than that under the monotonic load due to the accumulation of internal damage in concrete. The peak strain and ultimate strain of corroded concrete increased significantly with the increase in corrosion duration and enhanced by 55.7% and 77.9%, respectively, compared with the uncorroded concrete, whereas the peak stress and elastic modulus rapidly decreased and reduced by 53.3% and 74.1%, respectively. Moreover, based on the strength degradation depth, the concept of effective bearing cross-sectional area ratio was proposed to characterize the corrosion degree of concrete, and the correction coefficient of descending section for the effective bearing cross-sectional area ratio was introduced to establish the constitutive model of corroded concrete under cyclic load, and the results calculated by this model matched well with the experimental values. The research in this paper can provide the experimental and theoretical basis for seismic life cycle and fatigue redesign of concrete structures in acid corrosion environments or coastal areas.

Analysis of Concrete Corrosion Resistant Performance Based on the Coupled Action of Acid Rain and Carbonization

Reviews on the models and test Methods of Concrete Carbonation and some suggestions

Study on Mechanical Properties and Constitutive Relationship of Concrete Corroded by Hydrochloric Acid under Cyclic Load

Influence of Internal Temperature and Humidity in Concrete on the Corrosion Rate of Rebar

Research on the performance evolution of concrete under the coupling effects of sulfate attack and carbonation

Study on the Behavior and Durability of Reinforced Concrete in Boric Acid Environment

Optimal Design and Performance of Concrete with Function Component in Marine Environment

Investigation of the Effects of Acid Rain on the Deterioration of Cement Concrete Using Accelerated Tests Established in Laboratory

Mechanical Performance of Corroded Steel Bars in Concrete

The Effect of Acid Rain on Strength and Corrosion Performance of Slurry Infiltrated Fiber Concrete

Effect of Corrosion on Bond Behavior and Bending Strength of Reinforced Concrete Beams

Monotonic and fatigue behavior of steel-concrete composite beams subjected to corrosion

THE STATE OF THE ART OF CONCRETE STRUCTURE DURABILITY MONITORING AND RESTORATION

Study on Relation Between Early-age Performance of Concrete and Its Durability

Dynamic Self-Balanced Electrochemical Model for Non-Uniform Corrosion of Steel Reinforcement in Concrete under Combined Effects of Heat-Moisture-chlorine-oxygen

Analysis on steel corrosion at the cracking of concrete

Neutralization evolution of concrete under acid rain and carbonation erosion: A review

Study On Distribution Of Steel Corrosion Products In Concrete Structures

Experimental Investigation on the Influence of Strength Grade on the Surface Fractal Dimension of Concrete under Sulfuric Acid Attack

Grey Correlation Analysis of the Durability of Steel Fiber-Reinforced Concrete under Environmental Action

Predeterminate Model Of Corrosion Rate Of Steel In Concrete