Abstract:In this article, we report a controllable and reproducible approach to prepare highly ordered 2-D hexagonal mesoporous crystalline TiO2-SiO2 nanocomposites with variable Ti/Si ratios (0 to infinity). XRD, TEM, and N2 sorption techniques have been used to systematically investigate the pore wall structure, and thermal stability functioned with the synthetic conditions. The resultant materials are ultra highly stable (over 900 degrees C), have large uniform pore diameters (approximately 6.8 nm), and have high Brunauer-Emmett-Teller specific surface areas (approximately 290 m2/g). These mesostructured TiO2-SiO2 composites were obtained using titanium isopropoxide (TIPO) and tetraethyl orthosilicate (TEOS) as precursors and triblock copolymer P123 as a template based on the solvent evaporation-induced co-self-assembly process under a large amount of HCl. Our strategy was the synchronous assembly of titanate and silicate oligomers with triblock copolymer P123 by finely tuning the relative humidity of the surrounding atmosphere and evaporation temperature according to the Ti/Si ratio. We added a large amount of acidity to lower condensation and polymerization rates of TIPO and accelerate the rates for TEOS molecules. TEM and XRD measurements clearly show that the titania is made of highly crystalline anatase nanoparticles, which are uniformly embedded in the pore walls to form the "bricked-mortar" frameworks. The amorphous silica acts as a glue linking the TiO2 nanocrystals and improves the thermal stability. As the silica contents increase, the thermal stability of the resulting mesoporous TiO2-SiO2 nanocomposites increases and the size of anatase nanocrystals decreases. Our results show that the unique composite frameworks make the mesostructures overwhelmingly stable; even with high Ti/Si ratios (> or =80/20) the stability of the composites is higher than 900 degrees C. The mesoporous TiO2-SiO2 nanocomposites exhibit excellent photocatalytic activities (which are higher than that for commercial catalyst P25) for the degradation of rhodamine B in aqueous suspension. The excellent photocatalytic activities are ascribed to the bifunctional effect of highly crystallized anatase nanoparticles and high porosity.

Mesoporous Structure and Phase Transition of Nanocrystalline TiO2

The Thermal Analysis, Crystal Growth And Structure Transformation Of Nano-Scale Tio2 Prepared By Ticl4 Hydrolysis

Investigation of Mesoporous and Microporous Nanocrystalline Silicon-Doped Titania

Control of Microscopic Morphology and Structure of One Dimensional Titanium Dioxide Nanomaterials

Effect of Calcination Temperature on Crystal Structure and Photocatalytic Prop- Erty of TiO2/Diatomite Nanoparticles

Controllable and Repeatable Synthesis of Thermally Stable Anatase Nanocrystal-Silica Composites with Highly Ordered Hexagonal Mesostructures.

Transition of TiO 2 in TiO 2 /vermiculite Nanocomposites

In Situ Revealing the Dehydration and Atomic Structure Evolution of Protonated Titanate Nanotubes Via Environmental Transmission Electron Microscopy

Local structure modification and phase transformation of TiO2 nanoparticles initiated by oxygen defects, grain size, and annealing temperature

Crystallization and Phase Transition of Titanium Oxide Nanotube Arrays

Preparation of Anatase TiO2 Nanocrystalline and Research on Origion of Phase

Synthesis and characterization of nanosized anatase TiO2 cuboids

SAXS and XRD Studies on the Microstructure of TiO2 Nanoparticles

Synthesis, Phase Transition and Optical Properties of Nanocrystalline Titanium Dioxide Films Deposited by Plasma Assisted Reactive Pulsed Laser Deposition

Sol–gel Synthesis of Macroporous TiO 2 from Ionic Precursors Via Phase Separation Route

A Simple Solution-Phase Route for Room-Temperature Synthesis of Mesoporous and Nanocrystalline Anatase Tio2

An Amorphous-to-Anatase Phase Transition Study of TiO 2 Nanotubes by Temperature-Dependent Synchrotron-Based In Situ X-ray Diffraction

Study on Phase Transition of Nano-Size TiO2 During the Heat Treatment

Sol-gel Synthesis of Porous Crystalline TiO 2 –P 2 O 5 Oxide with Thermal Stability

Direct Synthesis of Controllable Microstructures of Thermally Stable and Ordered Mesoporous Crystalline Titanium Oxides and Carbide/Carbon Composites

Synthesis of Nanoscale Shell-Core Titania Coated Silica Particles in the Presence of Polyether Polyamine and the Phase Transition