Abstract:NOx and SO2 are the main air pollutants emitted from the coal-fired combustors. Since the typical combination of selective catalytic reduction (SCR) and we flue gas desulfurization (WFGD) is not suitable for some of industrial flue gas treatment due to their unsuitable temperature window and limited retrofitting space, new technologies must be developed. This paper proposes an effective we method for simultaneous removal of NOx and SO2. The insoluble NO was first oxidized into NO2 by ozone, and then NO2 together with SO2 were both absorbed in one we wash tower. To further improve NO2 removal efficiency, a new kind of additive was proposed and tested. Effects of various influence factors, such as additive concentration, residence time in the wash tower, liquid/gas ratios, initial NO/SO2/O-2 concentration and slurry pH value, were carefully evaluated in a home-designed experimental platform. Results indicated that the NOx removal efficiency was positively correlated with the increasing the additive concentration, while the maximum denitration and desulfurization efficiency were more than 95% and 86%. The NOx removal efficiency was enhanced with the increasing residence time and liquid/gas ratios. The alkaline environment was verified to be beneficial for the simultaneous absorption process. The exiting O-2 in flue gas would not consume additives, and the denitration and desulfurization efficiency were insensitive to the initial NO and SO 2 concentration as well. Only 2% decrease of the denitration efficiency was observed after 300 mins stability test, while the desulfurization efficiency kept > 98%. With the characterizations of Ion Chromatograph (IC), NO2-, NO3- and SO42- were detected as the main absorption by-products anions, whereas NO2- accumulation would inhibit the overall NOx removal. Finally, the mechanism of simultaneous removal of SO2 and NO using the novel liquid phase catalyst was proposed and discussed.

Removal of NO from Flue Gas by Wet Scrubbing with NaClO2/(NH2)2CO Solutions

Removal of NO and SO_2 from Flue Gas by Wet Scrubbing Using Aqueous NaClO Solution

Using Chlorine Dioxide to Remove NOx in Low-Temperature Flue Gas

Wet Oxidation and Absorption Procedure for NOx Removal

Removal of Nitric Oxide from Flue Gas with Iron Thiochelate Aqueous Solution in A Turbulent Contact Absorber

Integrated Tests for Removal of Nitric Oxide with Iron Thiochelate in Wet Flue Gas Desulfurization Systems

Investigation on removal of noX and SO2 from flue gas by combined ozone with absorption and by-product treatment

Absorption of NOx from flue gas with alkaline aqueous solution combined with gas-phase oxidation of NO using ozone

Performance and mechanism of CO2 absorption during the simultaneous removal of SO2 and NO by wet scrubbing process

Simultaneous Absorption of SO2 and NO from Flue Gas with CaCO3 and Liquid Phase Oxidation

Simultaneous Removal Of So2 And Nox From Flue Gas Using Acidic Naclo2/Naclo3 Solution

Removal of NOx from Flue Gas with Radical Oxidation Combined with Chemical Scrubber.

Removal of NO in Flue Gas Using Vacuum Ultraviolet Light/ultrasound/chlorine in a VUV-US Coupled Reactor

Investigation of NO Removal with Ozone Deep Oxidation in Na2CO3 Solution

A Superior Liquid Phase Catalyst for Enhanced Absorption of NO2 Together with SO2 after Low Temperature Ozone Oxidation for Flue Gas Treatment

Simultaneous wet desulfurization and denitration by an oxidant absorbent of NaClO2/CaO2

Simultaneous absorption of SO 2 and NO x from simulated flue-gas exploiting the enhancing oxidative ability of aqueous euchlorine as scrubbing solution

Simultaneous removal of SO2 and NOx by calcium hydroxide at low temperature: Effect of SO2 absorption on NO 2 removal

Experiment on Simultaneous Absorption of NO and SO2 from Sintering Flue Gas by Oxidizing Agents of KMnO4/NaClO

Oxidation Removal of Nitric Oxide from Flue Gas Using UV Photolysis of Aqueous Hypochlorite.

Removal of NOx form Flue Gas by Integration NaClO2 Solution and Surplus Heat Recovery