Abstract:Silica nanoparticles (nano-silica) were used as synergistic agents with ammonium polyphosphate (APP) and pentaerythritol (PER) to enhance flame retardancy of polypropylene (PP) in this research. The composites were prepared using a melt-mixing method. The influences of nano-silica on the fire performance of composites were thoroughly discussed, which promotes understanding of nano-silica on the flame-retardant performance of polypropylene composite. Scanning electron microscope (SEM) and energy-dispersive spectrometer (EDS) results indicated that the nano-silica with a diameter of about 95 ± 3.9 nm were dispersed favorably in the composite matrix, which might elevate its synergistic effect with intumescent flame retardant and improve the flame retardancy of polypropylene composite. The synergistic effects between nano-silica and intumescent flame retardant on PP composites were studied using the limiting oxygen index (LOI), UL-94 test, and cone calorimeter test (CCT). The total amount of flame retardant was maintained at 30%. When the dosage of nano-silica was 1 wt.%, the LOI value of PP/IFR/Si1.0 composite reached 27.3% and its UL-94 classification reached V-1. Based on the parameters of the CCT, the introduction of nano-silica induced composites with depressed heat release rate (HRR) and peak heat release rate (PHRR). The PHRR of PP/IFR/Si0.5 was only 295.8 kW/m2, which was 17% lower than that of PP/IFR. Moreover, the time to PHRR of PP/IFR/Si0.5 was delayed to 396 s, which was about 36 s later than that without nano-silica. EDS was used to quantitatively analyze the distribution of silica in charred residue. The EDS results indicated that the silica tended to accumulate on the surface during the fire. The surface accumulation characteristic of silica endows it with the enhanced flame-retardant properties of polypropylene composite at a very small dosage (as low as 1 wt.%).

An Investigation on Synergism of an Intumescent Flame Retardant Based on Silica and Alumina

Flame Retardation and Thermal Degradation of Intumescent Flame‐retarded Polypropylene Composites Containing Spirophosphoryldicyandiamide and Ammonium Polyphosphate

Synergistic Effect of SiO2 on Intumescent Flame-retardant Polypropylene

Synergistic Effect of SiO<sub>2</sub> on Intumescent Flame-retardant Polypropylene

Synergistic Flame Retardancy and Mechanism of Silicon-Containing Flame Retardant and Intumescent Flame Retardant

AN INVESTIGATION OF SYNERGISM BETWEEN SiO2, Al2O3 AND PP/APP/PER IFR SYSTEM THROUGH CONE CALORIMETER

Synergistic Effect of Silicon-Containing Compounds on Intumescent Flame Retardant Polypropylene

Synergistic Effect of Nano-Silica and Intumescent Flame Retardant on the Fire Reaction Properties of Polypropylene Composites.

Synergistic Effect Of Mesoporous Silica Sba-15 On Intumescent Flame-Retardant Polypropylene

Influence of Antimony Oxide on Flammability of Polypropylene/Intumescent Flame Retardant System

Synergistic effect of cocondensed nanosilica in intumescent flame-retardant polypropylene

Synergistic Effect of Compound Oxides with Intumescent Flame Retardant on the Properties of Polypropylene Composites

The Synthesis of a Novel Flame Retardant and Its Synergistic Efficiency in Polypropylene/ammonium Polyphosphate System

Synergistic Effect of Zeolite and Hindered Amine Containing Substances on Intumescent Flame Retardant Polypropylene

Synergistic Effects of Novel Intumescent Flame Retardant Polypropylene Composites

Synergistic effect of nano silicon and piperazine pyrophosphate/melamine polyphosphate on flame retardancy of polypropylene

Fire reaction properties of polystyrene-based composites using hollow silica as synergistic agent

A New Synergist for Intumescent Flame Retardant Polypropylene

Investigation of Novel Intumescent Flame Retardant Low‐density Polyethylene Based on SiO2@MAPP and Double Pentaerythritol

Synergistic effect of DOPO immobilized silica nanoparticles in the intumescent flame retarded polypropylene composites

Synergistic Effect of Sepiolite on Intumescent Flame Retardant Polypropylenes:TGA and XPS Studies