Study on the high adsorption performance and mechanism of acidic magenta using hydroxyapatite prepared from fish scales
Ruoyi Weng,Yanan Fan,Keyu Ren,Weiwei Jiang,Jingjie Hou,Jie Sheng,Yishan Song
DOI: https://doi.org/10.1007/s13399-023-04361-z
IF: 4.05
2023-06-20
Biomass Conversion and Biorefinery
Abstract:With the development of industrialization, dye pollution in water is becoming more and more serious. The rapid preparation of natural adsorbents from biological wastes to remove dye pollutants in water has attracted more and more attention. Natural adsorbents are widely available, environmentally friendly and inexpensive raw materials. Fish scales, which have low food value and are discarded in large quantities, are good raw materials for the extraction of natural adsorbents. In this paper, natural hydroxyapatite (HAp) was efficiently and concisely prepared from grass carp scales, and the adsorption characteristics of hydroxyapatite on acid fuchsin (AF) in water and the mechanism of its influence by three different drying methods, namely freeze-drying, hot air-drying, and natural draft-drying, were studied. The research results reveal that the natural-draft drying method among the three drying methods makes hydroxyapatite have the relatively largest specific surface area (BET test data proves this), which is mainly because under this method, the water gently escapes, the escaping kinetic energy is small, and the water molecules can be more widely, evenly and finely dispersed before evaporation, so that hydroxyapatite has the relatively smallest pore size and the largest number of pores. For this reason, in the Langmuir isotherm model which is more consistent with the experimental data, the maximum adsorption capacity (ND-HAp, 1259.60 mg g −1 ) of its fitting curve is the most satisfactory. Compared with the adsorption materials in the references of the same period, it has certain advantages. This is also the advantage that solar energy and wind energy are most directly used for drying adsorption materials, and the time cost can be greatly reduced in a reasonable planning. Kinetic and thermodynamic studies show that the adsorption process is exothermic and spontaneous, and is mainly controlled by single-layer chemical adsorption. The above conclusions provide some reference for the natural-draft drying method in the preparation and application of adsorbents, and also promote the application prospects of ND-HAp in the remediation of acid fuchsin wastewater, such as green, energy saving, and economic.
energy & fuels,engineering, chemical