Abstract:The growth and structural properties of ZnO thin films on Zn atoms both Au(111) and Cu(111) surfaces were studied using either NO2 or O-2 as oxidizing agent. The results indicate that NO2 promotes the formation of well-ordered ZnO thin films on both Au(111) and Cu(111). The stoichiometric ZnO thin films obtained on these two surfaces exhibit a flattened and non-polar ZnO(0001) structure. It is shown that on Au(111), the growth of bilayer ZnO nanostructures (NSs) is favored during the deposition of Zn in presence of NO2 at 300 K, whereas both monolayer and bilayer ZnO NSs could be observed when Zn is deposited at elevated temperatures under a NO2 atmosphere. The growth of bilayer ZnO NSs is caused by the stronger interaction between two ZnO layers than between ZnO and Au(111) surface. In contrast, the growth of monolayer ZnO NSs involves a kinetically controlled process. ZnO thin films covering the Au(111) surface exhibits a multilayer thickness, which is consistent with the growth kinetics of ZnO NSs. Besides, the use of O-2 as oxidizing agent could lead to the formation of substoichiometric ZnOx structures. The growth of full layers of ZnO on Cu(111) has been a difficult task, mainly because of the interdiffusion of Zn promoted by the strong interaction between Cu and Zn and the formation of Cu surface oxides by the oxidation of Cu(111). We overcome this problem by using NO2 as oxidizing agent to form well-ordered ZnO thin films covering the Cu(111) surface. The surface of the well-ordered ZnO thin films on Cu(111) displays mainly a moire pattern, which suggests a (3 x 3) ZnO superlattice supported on a (4 x 4) supercell of Cu(111). The observation of this superstructure provides a direct experimental evidence for the recently proposed structural model of ZnO on Cu(111), which suggests that this superstructure exhibits the minimal strain. Our studies suggested that the surface structures of ZnO thin films could change depending on the oxidation level or the oxidant used. The oxidation of Cu(111) could also become a key factor for the growth of ZnO. When Cu(111) is pre-oxidized to form copper surface oxides, the growth mode of ZnOx is altered and single-site Zn could be confined into the lattice of copper surface oxides. Our studies show that the growth of ZnO is promoted by inhibiting the diffusion of Zn into metal substrates and preventing the formation of sub-stoichiometric ZnOx. In short, the use of an atomic oxygen source is advantageous to the growth of ZnO thin films on Au(111) and Cu(111) surfaces.

Synthesis and characterization of one-dimensional ZnO nanostructures directly grown from and on Cu-Zn alloy substrate

Direct and Large-Area Growth of One-Dimensional ZnO Nanostructures from and on a Brass Substrate

Conversion of large-scale oriented ZnO rod array into nanotube array under hydrothermal etching condition via one-step synthesis approach

Co-synthesis of ZnO–CuO Nanostructures by Directly Heating Brass in Air

Structural Regulation and Optical Properties of One-Dimensional ZnO Nanomaterials in Situ Grown from and on Brass Substrates

Growth of 3-D Flower/Grass-Like Metal Oxide Nanoarchitectures Based on Catalyst-Assisted Oxidation Method

Growth And Characterization Of Cu-Catalyzed Zno Nanowires

Preparation and Photoluminescence of ZnO with Nanostructure by Hollow-Cathode Discharge

Field Emission and Optical Properties of ZnO Nanowires Grown Directly on Conducting Brass Substrates.

Facile and Controllable Growth of Zno 1d Nanostructure Arrays on Zn Substrate by Hydrothermal Process

One-Dimensional Zn-Doped in 2 O 3 -Sno 2 Superlattice Nanostructures

A Simple Route to Controllable Growth of ZnOnanorod Arrays on Conducting Substrates

Controllable Preparation of 1-D and Dendritic ZnO Nanowires and Their Large Area Field-Emission Properties

Cloned 3T6 cell line from CD-1 mouse fetal molar dental papillae.

Synthesis of two kinds of ZnO nanostructures by vapor phase method

Large-Scale Synthesis of Bicrystalline ZnO Nanowire Arrays by Thermal Oxidation of Zinc Film: Growth Mechanism and High-Performance Field Emission

Nucleation and growth of catalyst-free ZnO nanostructures

Growth of Ordered ZnO Structures on Au(111) and Cu(111)

Facile Synthesis and Photoluminescence Mechanism of ZnO Nanowires Decorated with Cu Nanoparticles Grown by Atomic Layer Deposition

The Synthesis and Crystallography of Some Novel ZnO Nano- and Micro-Crystals and Structures

One-Step Hydrothermal Synthesis of Comb-Like Zno Nanostructures