Abstract:Aeration scouring is currently the most common membrane fouling control technology. The optimization of aeration parameters, such as the aeration aperture, aeration pore spacing, and aerator layout height, can improve the efficiency of aeration and reduce the energy consumption of aeration. However, the simulation results cannot guide engineering practices well due to the limitations in the model precision of computational fluid dynamics. On this basis, the study compared and selected the computational fluid dynamics turbulence model. The DES model was used to study the influence of aeration parameters on membrane fouling control. The study showed that the DES turbulence model had a higher precision and accuracy in predicting the average shear force and the instantaneous shear force distribution on the membrane surface than the k-epsilon turbulence model. The average error of the DES turbulence model simulation of a bubble height was only 1.33%, which was 14.33% lower than the 15.66% of k-epsilon. An aeration pore spacing of 20 mm, a height of 100 mm, and an aeration aperture of 2.0 mm were the best layout parameters. The degree of influence of the aeration aperture, the aeration pore spacing, and the height of the aerator layout on the shear force of the membrane surface decreased sequentially. The influence of each interaction on the average shear force of the membrane surface was negligible. Among these parameters, the main reason for the membrane surface shear force was the change in the flow velocity caused by aeration. By calculating the fitting equation and the critical value of the shear force, the critical value of the liquid velocity on the membrane surface that could remove membrane fouling was 0.232 m/s. Although the numerical simulation and optimization of a flat membrane bioreactor air scouring for membrane fouling control were carried out with pure water, it still plays a significant impact on the actual membrane fouling control. These results could guide the optimization design of aeration parameters for flat membrane bioreactors and provide a reference for the analysis of aeration scour control membrane pollution control research.

Experiment and Calculation of Filtration Processes in an External-Loop Airlift Ceramic Membrane Bioreactor

Modeling of Cross-Flow Filtration Processes in an Airlift Ceramic Membrane Reactor

[Membrane Fouling Control in a Free-End Comb-Like Hollow Fiber Membrane Bioreactor].

[Research on Critical Aerating Flux of Internal-Loop Granular Sludge Bed Nitrifying Reactor].

Modeling of CO2 Mass Transport Across a Hollow Fiber Membrane Reactor Filled with Immobilized Enzyme

Quantitative relationships for the impact of gas sparging conditions on membrane fouling in anaerobic membrane bioreactor

Numerical Simulation and Optimization of a Cold Model of a Flat Membrane Bioreactor Air Scouring for Membrane Fouling Control

Influence of Ceramic Membrane Surface Characteristics on the Flux Behavior of a Complex Fermentation Broth

Critical flux enhancements with air sparging in axial hollow fibers cross-flow microfiltration of biologically treated wastewater

Computational fluid dynamic for improving design and performance of an external loop airlift reactor used in electrochemical wastewater treatment

Investigating effective strategies for sustainable operation of a submerged anaerobic membrane bioreactor (SAnMBR) coupled with ceramic ultrafiltration membrane

Hydraulic optimization of membrane bioreactor via baffle modification using computational fluid dynamics.

Investigation of hydrodynamics and mass transfer in an internal loop airlift slurry reactor integrating mixing and separation

Simulation And Experimentation On The Gas Holdup Characteristics Of A Novel Oscillating Airlift Loop Reactor

Experimental Study and Cfd Simulation of Hydrodynamic Behaviours in an External Loop Airlift Slurry Reactor

Hydrodynamics and mass transfer in a slurry external airlift loop reactor integrating mixing and separation

Modelling the three‐phase flow in a pilot‐scale airlift internal‐loop reactor for wastewater treatment

Flow Behavior and Mass Transfer in Three-Phase External-Loop Airlift Reactors with Large Particles

Hydraulic flow pattern and performance of swirling flow anaerobic attached growth film expanded bed bioreactor

Aggravation of membrane fouling and methane leakage by a three-phase separator in an external anaerobic ceramic membrane bioreactor

Successful Application of Shirasu Porous Glass (SPG) Membrane System for Microbubble Aeration in a Biofilm Reactor Treating Synthetic Wastewater