Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Condensation Induced by Rarefaction Waves and Reflected Rarefaction Waves

Vapor Condensation in Rayleigh–Bénard Convection

Droplet Evaporation to Boiling in Van Der Waals Fluid

Abnormal Condensation of Water Vapour at Ambient Temperature.

On the Early and Developed Stages of Surface Condensation: Competition Mechanism Between Interfacial and Condensate Bulk Thermal Resistances

Visualization Experiment and Numerical Simulation of Nitrogen-Neon Mixture Condensation

Theoretical Modeling of Vapor Condensation in the Presence of Noncondensable Gas on a Horizontal Tube

Visualization study of the influence of non-condensable gas on steam condensation heat transfer

Numerical study on transonic flow of moist air with non-equilibrium condensation

Numerical and Experimental Investigation on Water Vapor Condensation in Turbulent Flue Gas

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube

Abnormal condensation of nanoscale water drops at ambient temperature

Condensation of vapor in the presence of non-condensable gas in condensers

Diffusion Layer Model for Condensation of Vapor with the Presence of Noncondensable Gas under Natural Convective Condensation

Numerical Research on Nitrogen Spontaneous Condensation in Converging-Diverging Nozzle

A Molecular Dynamics Study on Growth of Condensation Film on A Solid Surface

The condensation characteristics of individual droplets during dropwise condensation

Subsonic and supersonic gas flows to condensation surface

Experimental and theoretical investigation on condensation inside a horizontal tube with noncondensable gas

Effects of Liquid Film Waviness, Suction, and Fog Formation on Condensation in the Presence of Noncondensable Gases

Modeling of self-excited oscillation of non-equilibrium condensation in transonic moist air flow