Abstract:A novel composite retaining system that combines artificial ground freezing (AGF) and diaphragm walls for a real construction project is presented in this work. In this project, a deep excavation was conducted above a tunnel with a minimum clearance of 0.8 m between the final excavation surface and the tunnel crown. The diaphragm walls were constructed as retaining walls. However, the existence of the underlying tunnel impedes the integrality of the diaphragm walls around the tunnel and causes the problems of poor reinforcement and unblocked seepage paths. To address this conflict, several freezing pipes were drilled and installed outside the diaphragm wall to form a large-scale frozen curtain. Through the composite retaining wall, the generation of the dual effect of ground reinforcement and waterproof sealing was also accomplished. Field measurements were conducted to investigate the performance of the excavation including temperature distributions, deformation variations, and pore-water pressure developments. From the acquired field data, it was revealed that a 7 m-width x 3 mthickness frozen wall was formed for the subsequent excavation and the vertical displacement of the underlying tunnel was controlled at a distance of 9.3 mm to guarantee the safe operation. On top of that, during the AGF construction, the composite retaining wall met the requirements of high strength and stiffness, as well as practically zero permeability. From this case study, it is demonstrated that the proposed construction technology possesses comparative advantages in resolving the conflict between the adjacent excavation and the existing tunnels for controlling the excavation-induced deformation and decreasing the construction risk.

APPLICATION OF POST-GROUTING TO END OF DEEP DIAPHRAGM WALL EMBEDDED IN ROCKS

Grouting experiment in a completely weathered granite dam abutment: case study on grouting technique and test analysis

Study on Optimal Grouting Timing for Controlling Uplift Deformation of a Super High Arch Dam

Study on Failure Mode of Underground Diaphragm Wall in Soft Soil Area

An extended discontinuous deformation analysis (DDA) for simulation of grouting reinforcement in a water-rich fractured rock tunnel

Development and application of new composite grouting material for sealing groundwater inflow and reinforcing wall rock in deep mine

Seepage failure of a foundation pit with confined aquifer layers and its reconstruction

Performance of a Deep Excavation with the Composite Retaining Wall Using Artificial Ground Freezing Method

Study of Consolidation Grouting Effect for Downstream Block of High Arch Dams

Case Study on the Method of Rock Mass Overburden Consolidation Grouting for Dam Foundation

Case Study: In Situ Experimental Investigation on Overburden Consolidation Grouting for Columnar Jointed Basalt Dam Foundation

Rapid Reinforce Grouting System for Surrounding Rock Masses in Large Underground Water-sealed Storage Caverns

Study on the Construction Method and Effects of Ipsilateral, Multi-Nozzle, High-Pressure Jet Grouting Cut-Off Wall

STUDY OF BLOCKAGE ACCIDENT OF PRE-EMBEDMENT GROUTING PIPES AND ITS CORRESPONDING TREATMENT METHOD

Application and Development of New Technology for Support of Deep Excavations in Coastal Areas of Zhejiang

Grouting Construction Technology in Anti-seepage Treatment of Reservoir

Application of New Theories and Technology for Grouting of Dams and Foundations on Rock

Development and application of novel microfine cement-based grout

Method for controlling leakage of grouting treatment vertical type asphalt concrete core wall earth-rock dam

EVALUATION OF APPLICATION EFFECT OF CEMENT-CHEMICAL COMPOUND GROUTING IN FAULT REINFORCEMENT

Research on Construction Technology of Combined Omni-directional High-pressure Jet Pile