Abstract:The utilization of powdery semi-coke as a power fuel in pulverized coal-fired power plants has become a new and potential technique to consume the excess powdery semi-coke. The characteristic of low volatile results in poor combustion performance and high NOx emission, and to co-fire with bituminous coal is a practical strategy to address this problem. However, the co-combustion characteristics and the inherent interaction between semi-coke and coal remain insufficiently understood. In addition, the influences of secondary air arrangement, the boiler operation load, and the fuel type on co-combustion process are still unclear, which is urgent to be further explored. In the present study, experiments and numerical simulations were jointly utilized to inquire into the co-combustion behaviors and NOx emission features of semi-coke and coal. The results demonstrated that the “out-furnace method” was a suitable choice for small-capacity boiler when the proportion of semi-coke was 33%, due to the limited combinations of the semi-coke injection position. It was recommended that semi-coke was preferred to be injected from the middle layers of the furnace under the “in-furnace method” to improve the overall co-combustion performance. The critical value of the separated over fire air ratio in this study was 27.5%, over which a slight drop of carbon content in fly ash could come about. Moreover, the elevation in the proportion of separated over fire air gave rise to the significant decline of NOx concentration. The constricted secondary air arrangement was preferred to be employed due to the high boiler efficiency. The separated over fire air and the surrounding air needed to maintain a wide-open degree to prevent the increase of NOx emissions and the coking of nozzles. For the load reduction regulation method adopted in this study, the NOx concentration first rose and then dropped, while the burnout ratio decreased obviously as the operation load was reduced. Different combinations of coal and semi-coke generated significant influences on co-combustion behaviors within the furnace. The NOx generated by high-volatile fuel (bituminous coal) combustion was mainly affected by volatile-N, while the NOx generated by low-volatile fuel (semi-coke) was mainly impacted by char-N. This study is of guiding significance for the efficient and clean utilization and beneficial to the large-scale application of powder semi-coke in power plants.

An Experimental Study of the Combustion Characteristics of Coal Gasification Semi-coke in a Pilot-scale Pressurized Fluidized Bed

Experimental Study on Combining Partial Gasification With Air on a Fluidized Bed at Atmospheric Pressure and Semi-coke Combustion

Experimental Investigation on the Coal Combustion in a Pressurized Fluidized Bed

Air Blown Partial Gasification of Coal in a Pilot Plant Pressurized Spout-Fluid Bed Reactor

Effect of Temperature on Coal Partial Gasification Behavior in a Pilot-Scale Pressurized Spout-Fluid Bed Gasifier

Simulation of Coal Gasification in a Pressurized Spout‐fluid Bed Gasifier

Study on Partial Gasification Characteristics of Coal in a 2MW Pressurized Spout-fluidized Bed

Experimental Study on Coal Gasification in Interconnected Fluidized Bed

3D Simulation on Pressurized Oxy-Fuel Combustion of Coal in Fluidized Bed

Experimental and Numerical Study on Co-combustion Behaviors and NOx Emission Characteristics of Semi-coke and Coal in a Tangentially Fired Utility Boiler

Characteristics of Coal Partial Gasification Experiments on a Circulating Fluidized Bed Reactor under CO2-O-2 Atmosphere

Results of Bituminous Coal Gasification upon Exposure to a Pressurized Pilot-Plant Circulating Fluidized-Bed (CFB) Reactor

Partial gasification of coal in a fluidized bed reactor: Comparison of a laboratory and pilot scale reactors

EXPERIMENTAL STUDY ON GASIFICATION IN DUAL FLUIDIZED BEDS

Study On Pollutants Emission Characteristic Of Coal Gasification In A Fluidized Bed Test Rig

Development of Coal Partial Gasification and Combustion System

A pilot scale test on the fluidized melting combustion of coal gasification fine slag

Coal Combustion Emissions and Ash Formation Characteristics During Oxy-Fuel Combustion in a 100 Kwth Pressurized Circulating Fluidized Bed

Characteristics of Coal Partial Gasification on A Circulating Fluidized Bed Reactor

Experimental Investigation of Oxy-coal Combustion in a 15 Kw(th) Pressurized Fluidized Bed Combustor

Simulations of Coal Combustion in a Pressurized Supercritical CO2 Circulating Fluidized Bed