Abstract:The microstructure evolution of Ni-based superalloys during heat treatment is of great significance for obtaining better service performance. However, heat treatment experimentation is costly and time-consuming, and sometimes fails to reveal physical mechanisms well. In the present study, a multiphase-field model coupled with an explicit nucleation algorithm was established to simulate the precipitation and growth of γ′ phase in DD6 superalloy, which can be applied to a multicomponent elastic-inhomogeneous system. The PanNickel© database was used to calculate thermodynamic and kinetic data in multicomponent superalloys. First, the coupling method of multiphase-field model and explicit nucleation algorithm was introduced. The coupled model was used to simulate the precipitation of γ′ phase under isothermal and non-isothermal conditions. It was found that a unimodal microstructure was formed under isothermal conditions and there was a “soft impingement” phenomenon, while a bimodal distribution composed of cuboidal γ′ precipitates and fine secondary γ′ precipitates was formed during a cooling process of 25–125 °C/min. The effect of cooling rate was studied. Then, the chemical and elastic driving forces were analyzed. It was found that Al and Ta contributed most to the chemical driving force, while Re and W gathered at the γ/γ′ interface and inhibited the growth of γ′ phase. γ′ precipitates had a cuboidal shape under the influence of elastic driving force. Finally, the growth and coarsening process of γ′ phase was studied and compared with the well-known Lifshitz−Slyosov−Wagner (LSW) theory. The growth of γ′ phase can be divided into rapid growth, coarsening and quasi-static coarsening stages according to the simulation results, among which the coarsening stage is basically consistent with the LSW theory. The current model can be used to simulate the precipitation and growth of single crystal superalloys where multicomponent and elastic effects are considered.

Investigation of the Size Effect of Nickel-Base Superalloy Single Crystals Based on Strain Gradient Crystal Plasticity

Size effects of γ′ precipitate on the creep properties of directionally solidified nickel-base super-alloys at middle temperature

Effect of Alloying Elements on Lattice Misfit and Elasticities of Ni-based Single Crystal Superalloys by First-Principle Calculations

Size Effects Of Gamma ' Precipitate On The Creep Properties Of Directionally Solidified Nickel-Base Super-Alloys At Middle Temperature

Influence of Cooling Rate on the Formation of Bimodal Microstructures in Nickel-Base Superalloys During Continuous Two-Step Aging

Temperature Effects on Deformation Substructures and Mechanisms of a Ni-based Single Crystal Superalloy

PRECIPITATE SIZE AND MORPHOLOGY EFFECTS ON THE CREEP BEHAVIOR OF NICKEL-BASE SUPERALLOYS

Nanoscale Origins of the Size Effect in the Compression Response of Single Crystal Ni-Base Superalloy Micro-Pillars

The Effect of Stress Gradient on the Formation of TCP Phases in a Ni-based Single Crystal Superalloy at 1050 Oc

Multiphase-field and experimental study of solidification behavior in a nickel-based single crystal superalloy

Plastic Deformation and Recrystallization of a Ni-Based Single Crystal Superalloy

A Molecular Dynamics Study on the Dislocation-Precipitate Interaction in a Nickel Based Superalloy During the Tensile Deformation

Size effect on the forming limit of a nickel-based superalloy thin sheet at the mesoscopic scale

Deformation and recrystallization of single crystal nickel-based superalloys during investment casting

Experimental Investigation on Recrystallization Mechanism of a Ni-base Single Crystal Superalloy

Precipitation and Growth Simulation of Γ′ Phase in Single Crystal Superalloy DD6 with Multiphase-Field Method and Explicit Nucleation Algorithm

Phase-field modeling of $γ/γ''$ microstructure formation in Ni-based superalloys with high $γ''$ volume fraction

Experimental and Numerical Studies on Recrystallization Behavior of Single-Crystal Ni-Base Superalloy

Ultra high-temperature deformation in a single crystal superalloy: Meso-scale process simulation and micro-mechanisms

Molecular dynamics simulation of the γ’ phase deformation behaviour in nickel-based superalloys

Effect of biphasic interface on mechanical properties and deformation mechanism of nickel base alloy