Abstract:The co-removal of CO2 while removing SO2 and NOx from industrial flue gas has great potential of carbon emission reduction but related research is lacking. In this study, a wet scrubbing process with various urea solutions for desulfurization and denitrification was explored for the possibility of CO2 absorption. The results showed that the urea-additive solutions were efficient for NOx and SO2 abatement, but delivered < 10% CO2 absorption efficiency. The addition of Ca(OH)2 dramatically enhanced the CO2 absorption, remained the desulfurization efficiency, unfortunately restricted the denitrification efficiency. Among various operating parameters, pH of solution played a determining role during the absorption. The contradictory pH demands of CO2 absorption and denitrification were observed and discussed in detail. A higher pH of solution than 10 was favorable for CO2 absorption, while the oxidizing of NO to NO2, NO2- or NO3- by NaClO2 was inhibited in this condition. When 7 < pH < 10, it was favorable for the conversion and absorption of NO and NOx. However, the conversion of HCO3- to CO32- was significantly inhibited, hence preventing the absorption of CO2. Large part of Ca(OH)2 became CaCO3 with a finer particle size, which covered the unreacted Ca(OH)2 surface after the reaction. Kinetic analysis showed that the CO2 absorption in urea-NaClO2-Ca(OH)2 absorbent was controlled by chemical reaction in early stage, then by ash layer diffusion in later stage.

Kinetics of Gas–liquid Reaction Between NO and Co(NH3)62+

Kinetics of gas-liquid reaction between NO and Co(NH3)6(2+).

KINETICS OF GAS-LIQUID REACTION OF NO WITH Co (NH3)2+6

Kinetics of Gas−Liquid Reaction between NO and Co(en)<sub>3</sub><sup>3+</sup>

Kinetics for the Simultaneous Absorption of Nitric Oxide and Sulfur Dioxide with the Hexamminecobalt Solution

Kinetics of gas-liquid reaction between NO and Co(en)33+

On the kinetics of the absorption of nitric oxide into ammoniacal cobalt(II) solutions

Kinetics of NOx absorption into (NH4) 2SO3 solution in an ammonia-based wet flue gas desulfurization process

Kinetics for the Simultaneous Removal of NO and SO2 with Cobalt Ethylenediamine Solution

Wet Oxidation and Absorption Procedure for NOx Removal

Adsorption–Reduction Behavior of Co(NH3) on Activated Carbon

Nitric oxide absorption into cobalt ethylenediamine solution

Experimental Determination of Equilibrium Constant for the Complexing Reaction of Nitric Oxide with Hexamminecobalt(ii) in Aqueous Solution.

Removal of Sulfur Dioxide and Nitric Oxide Using Cobalt Ethylenediamine Solution

Experimental Study on the Simultaneous Removal of SO_2 and NO by High Efficiency Liquid Absorbent

Removal of Dilute Nitric Oxide Using Cobalt Diethylenetriamine Solution under Aerobic Condition

Oxidative catalytic absorption of NO in aqueous ammonia solution with hexamminecobalt complex

Studies on removal of NO with ammoniac cobalt solution

Simultaneous Absorption of NO and SO2 into Hexamminecobalt(ii)/iodide Solution.

Performance and mechanism of CO2 absorption during the simultaneous removal of SO2 and NO by wet scrubbing process

Removal of NO with [Co(en)3]2+ Solution