Abstract:An investigation on biohydrogen production was conducted in a granular sludge-based continuous stirred tank reactor (CSTR). The reactor performance was assessed at five different glucose concentrations of 2.5, 5, 10, 20 and 40g/L and four hydraulic retention times (HRTs) of 0.25, 0.5, 1 and 2h, resulting in the organic loading rates (OLRs) ranged between 2.5 and 20g-glucose/Lh. Carbon flow was traced by analyzing the composition of gaseous and soluble metabolites as well as the cell yield. Butyrate, acetate and ethanol were found to be the major soluble metabolite products in the biochemical synthesis of hydrogen. Carbon balance analysis showed that more than half of the glucose carbon was converted into unidentified soluble products at an OLR of 2.5g-glucose/Lh. It was found that high hydrogen yields corresponded to a sludge loading rate in between 0.6 and 0.8g-glucose/g-VSSh. Substantial suppression in hydrogen yield was noted as the sludge loading rate fell beyond the optimum range. It is deduced that decreasing the sludge loading rate induced the metabolic shift of biochemical reactions at an OLR of 2.5g-glucose/Lh, which resulted in a substantial reduction in hydrogen yield to 0.36–0.41mol-H2/mol-glucose. Optimal operation conditions for peak hydrogen yield (1.84mol-H2/mol-glucose) and hydrogen production rate (3.26L/Lh) were achieved at an OLR of 20g-glucose/Lh, which corresponded to an HRT of 0.5h and an influent glucose concentration of 10g/L. Influence of HRT and substrate concentration on the reactor performance was interrelated and the adverse impact on hydrogen production was noted as substrate concentration was higher than 20g/L or HRT was shorter than 0.5h. The experimental study indicated that a higher OLR derived from appropriate HRTs and substrate concentrations was desirable for hydrogen production in such a granule-based CSTR.

Biological hydrogen production in continuous stirred tank reactor systems with suspended and attached microbial growth

[Continuous Operation of Hydrogen Bio-Production Reactor with Ethanol-Type Fermentation].

Continuous Bio-Hydrogen Production Using Activated Carbon As Solid Carriers from Molasses Fermentation

Continuous Biohydrogen Production from Diluted Molasses in an Anaerobic Contact Reactor

Production of hydrogen in a granular sludge-based anaerobic continuous stirred tank reactor

[Characteristics and Operation of Enhanced Continuous Bio-Hydrogen Production Reactor Using Support Carrier].

Start-up and Continuous Operation of Continuous Stirred-Tank Reactors (CSTR) Using Ethanoligenens Harbinense R3

Start-up and Continuous Operation of Bio-Hydrogen Production Reactor at Ph 5

Comparison of Fermentative Hydrogen Production from Molasses in Two Continuous Stirred Tank Reactors: CSTR Versus ACR

Microbial Community Structure of Ethanol Type Fermentation in Bio-Hydrogen Production

Operation characteristics of biohydrogen production in continuous flow anaerobic system for treating wastewater of beet-sugar processing

Fermentative Hydrogen Production from Beet Sugar Factory Wastewater Treatment in a Continuous Stirred Tank Reactor Using Anaerobic Mixed Consortia

Simultaneous Biohydrogen Production and Wastewater Treatment in Continuous Stirred Tank Reactor (cstr) Using Beet Sugar Wastewater

Biological Fermentative Hydrogen and Ethanol Production Using Continuous Stirred Tank Reactor

Continuous Bio-Hydrogen Production by Mesophilic and Thermophilic Cultures

Fermentative hydrogen production from molasses wastewater in a continuous mixed immobilized sludge reactor.

Effect of hydraulic retention time on the hydrogen production in a horizontal and vertical continuous stirred-tank reactor

Effect of Chemical Oxygen Demand (COD) on Hydrogen Production from Waste Molasses in Continuous Stirred Tank Reactor (CSTR)

Hydrogen-producing Capability of Anaerobic Activated Sludge in Three Types of Fermentations in a Continuous Stirred-Tank Reactor

Fermentative hydrogen production from beet sugar wastewater in a continuous stirred tank reactor (CSTR): Effect of hydraulic retention time (HRT)

Start-up and Performance of Anaerobic Contact Reactor for Hydrogen Production