Abstract:The pile foundation cutting and underpinning process during shield tunnelling significantly impacts the stability of bridge substructures. In this paper, the shield tunnel area from Hongguzhong Avenue Station to Yangming Park Station of Nanchang Metro Line 2 was taken as the research subject, which crosses the pile foundation underpinning project of the south approach section of Bayi Bridge. Through numerical simulation and on-site monitoring analysis, the influence of the active underpinning process of shield tunnelling pile foundation on the deformation of bridge substructure was studied. First, through analyzing on-site conditions and comparing technical solutions, an active gantry bridge pile foundation underpinning technology was proposed, and the specific construction steps were determined. On this basis, for the C15 pile foundation with the most complex working conditions, ABAQUS software was applied to simulate the jack-up, unloading and pile-cutting process during the pile foundation underpinning construction, and the displacement development of the bridge pier, underpinning beam and new pile during the whole construction process were analyzed. Finally, through on-site monitoring data analysis, the technology’s feasibility and safety were further verified. At the same time, according to the analysis of the monitoring results of the bridge piers, underpinning beams and new piles, the results from the finite element software were nearly the same as the trend shown by the monitoring results, and the displacement of the main structures of the lower part of the bridge was small and within the control range. The above research work verified the applicability of the active gantry type bridge pile foundation underpinning technology in the pile foundation underpinning condition of the single-column single-pile bridge in the narrow space curved bridge section, and is worthy of further promotion and application.

Analyses and Monitoring of Highway Bridge Piles Constructed on Steep Slopes

Three-dimensional finite element modelling for seismic response analysis of pile-supported bridges

Analysis of the influence of open-cut undercrossing of a national highway in Hangzhou on the existing municipal viaduct piers

Study on causes of post-construction settlement of DJM pile composite foundation at bridge approaches

Characteristic study on composite foundation with rigid-flexible piles under the load from embankment

Field Experimental Study on Compound Foundation of Dry Jet Mixing Pile in Highway

Analysis of cast-in-situ tubular piles in soft foundation improvement at bridge approaches

Multi-Source Monitoring and Numerical Simulation Deformation on Highway Steep Slopes under Rainfall Effects

Monitoring and Analysis of the Impact of Adjacent Bridge Pile Construction on Subway Tunnels

Analysis of the Deep-Seated Concrete Slab for Settlement Control at Bridge Approach Embankment

FIELD SURVEY OF COMPOSITE FOUNDATION WITH RIGID PILES UNDER EMBANKMENT

Investigation on the Influence of Active Underpinning Process on Bridge Substructures During Shield Tunnelling: Numerical Simulation and Field Monitoring

Analysis and Field Monitoring on the Effect of High Earth Embankment on the Existing Large Span Bridge Pile foundations

Field Measurement Analysis of the Influence of Double Shield Tunnel Construction on Reinforced Bridge

Safety Analysis for Bridge Pier under Nearby Road Construction and Operation

Analysis of Support Abutments of Curved Bridges with Single-pedestal Piers

Strain-Based Structural Condition Assessment of an Instrumented Arch Bridge Using Fbg Monitoring Data

Field Test of Two Methods for Alleviating Bridge-Head Jumping at Deep Soft Foundation

Field Monitoring of Geogrid-Reinforced and Pile-Supported Embankment at Bridge Approach

Monitoring and stability analysis of roadbed & high slope prior to highway construction

Research Of Full-Life Monitoring For Long Span-Bridge