Abstract:A series of MnCo/Cu-ZSM-5 (MnCo/Cu-Z) catalysts with different Mn/Co ratios for the selective catalytic reduction (SCR) of NO with NH3 were prepared by the combination of ion exchange and impregnation. The physicochemical properties of the catalysts were investigated by N2 adsorption/desorption, X-ray diffraction (XRD), temperature-programmed reduction with hydrogen (H2-TPR), X-ray photoelectron spectroscopy (XPS), and temperature-programmed desorption of NOx (NOx-TPD) and NH3 (NH3-TPD), and the diffuse reflectance infrared Fourier transform (DRIFT) technique was employed for the detection of intermediate species and the study of the mechanism. The introduction of Mn and Co boosts the catalytic activity of the Cu-Z catalyst at a temperature below 200 °C, and the optimum activity was obtained over the Mn1Co2/Cu-Z catalyst. The enrichment of the high-valent metal ion on the catalyst surface and the improvement in the reducibility of metal oxide are responsible for the elevation in the catalytic activity of MnCo/Cu-Z. The bridged and bidentate modes are the prevailing nitrate species on the Cu-Z and MnCo/Z catalysts, respectively, and both of them were detected over the MnCo/Cu-Z catalyst. Furthermore, the DRIFT spectroscopy (DRIFTS) results indicate that, at 150 °C, the bridged nitrate can react with the adsorbed ammonia species, but the bidentate nitrate fails to do. The SCR reaction over the Cu-Z catalyst follows the Eley–Rideal and Langmuir–Hinshelwood mechanisms simultaneously at 150 °C, whereas an overwhelming dominance of the Eley–Rideal mechanism is identified for the MnCo/Z catalyst. As to the SCR mechanism on the MnCo/Cu-Z catalyst, it combines the features of Cu/Z and Mn1Co2/Z.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acscatal.1c01172?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acscatal.1c01172</a>.Physical properties of catalysts; peak positions and assignments in the DRIFT Spectra; effects of H2O on NOx conversion; effects of H2O on the stability of catalysts; EDS element mapping of catalysts; and relative amount of surface acid sites (<a class="ext-link" href="/doi/suppl/10.1021/acscatal.1c01172/suppl_file/cs1c01172_si_001.pdf">PDF</a>)This article has not yet been cited by other publications.

Enhanced Low-Temperature Activity of Ag-Promoted Co-ZSM-5 for the CH 4 -SCR of NO

Effect of addition of Zn on the catalytic activity of a Co/HZSM-5 catalyst for the SCR of NOx with CH4

On the selectively catalytic reduction of NOx with methane over Ag-ZSM-5 catalysts

Promotional effect of colloidal alumina on the activity of the In/HZSM-5 catalyst for the selective reduction of NO with methane

Optimization of Promoter and Support for Co-based/ zeolites Catalysts in Catalytic Reduction of NOx by CH4

Studies On Selectively Catalytic Reduction Of Nox By Methane Over Ag-Zsm-5 Catalysts

Low-temperature selective catalytic reduction of NO with propylene in excess oxygen over the Pt/ZSM-5 catalyst.

Selective Catalytic Reduction of NO over Mo/ZSM-5 Catalyst

Mechanistic study of NO reduction with methane over Co2+ modified ZSM-5 catalysts

No Reduction by Ch4 in the Presence of Excess O-2 over Mn/Sulfated Zirconia Catalysts

Bifunctional Catalyst of CuMn-HZSM-5 for Selective Catalytic Reduction of NO and CO Oxidation under Oxygen Atmosphere

Comparative study of ZSM‐5 supported transition metal (Cu, Mn, Co, and Fe) nanocatalysts in the selective catalytic reduction of NO with NH3

Remarkable low temperature catalytic activity for SCR of NO with propylene under oxygen-rich conditions over Mn0.2La0.07Ce0.05Ox/ZSM-5 catalyst

A novel Cu-Mo/ZSM-5 catalyst for NOx catalytic reduction with ammonia

The Influence of Reduction Temperature on the Performance of ZrOx/Ni-MnOx/SiO2 Catalyst for Low-Temperature CO2 Reforming of Methane

Activity enhancement of bimetallic Co-In/Al2O3 catalyst for the selective reduction of NO by propene

Comparison of catalytic activities for SCR of NO by propane over Me/γ-Al2O3 and Me/ZSM-5 in the excess of oxygen

Low-temperature CO2 Reforming of Methane on Zr-promoted Ni/SiO2 Catalyst

Cu-ZSM-5 Catalyst Impregnated with Mn–Co Oxide for the Selected Catalytic Reduction of NO: Physicochemical Property–Catalytic Activity Relationship and In Situ DRIFTS Study for the Reaction Mechanism

Promotional Effect of Cr on the Activity of In/Wo3/Zro2 for Selective Reduction of No with Methane

Selective Catalytic Reduction of NOx with Methane over Cobalt-Exchanged SSZ-39 Zeolite