Abstract:In order to investigate the boundary characteristics of density wave oscillations in nuclear reactor steam generators and boiler water-cooled wall tubes, a frequency domain method numerical calculation model applicable to different geometrical structures and operating parameters was developed. In order to make the results of the model more accurate, the state of the fluid at the outlet of the heated pipe and the time delay were fully considered on the basis of the traditional model. Depending on the physical properties of the fluid at the outlet of the heated pipe, the model calculation area was divided into single-phase, two-phase and superheated zones. Small-perturbation linearization and Laplace transform were performed on the conservation equations in the three regions. The Nyquist stability criterion was used in matlab software to judge the stability of the flow, and by varying the working parameters the flow instability boundary can be calculated. For a more in-depth study of density wave oscillations in heated pipes, the unstable boundary characteristics were analysed computationally for different influences such as pressure, mass flow rate, inlet subcooling degree and pipe geometry on the basis of model validation. In addition, the Nyquist function was used in Matlab to plot the Nyquist curve for different influencing factors and to analyse the stability margins for specific operating conditions. The unstable boundary characteristic diagram was obtained when the pressure was 5–10 MPa and the mass flux was 300–1300 kg·m −2 ·s −1 . The calculated data was collated and mass flow rate and heat load boundary diagrams were plotted, which could visualise the boundary characteristics of the density wave oscillations under different operating conditions. In order to make the calculation results more applicable, N sub and N pch were used to construct the dimensionless unstable boundary characteristic diagram. Results showed that the influence of inlet subcooling degree on flow stability is non-monotonic. In addition, the effects of factors such as pressure, mass flow rate and inlet throttling coefficient are monotonic.

Acoustic Wave Prediction in Flowing Steam-Water Two-Phase Mixture

Thermoacoustic Model For Time-Averaged Flowing Streaming Within Parallel Plate And Cylindrical Tube Subjected To Oscillating Flow

Numerical Simulation of Nonlinear Phenomena in a Standing-Wave Thermoacoustic Engine with Gas-Liquid Coupling Oscillation

Investigation on Heat Transfer and Flow of a Sonic Steam Jet Condensation in Crossflow of Water in Pipes

Numerical Study on the Evolution Characteristics of Phase Interface of Subsonic and Sonic Steam Jets in Transverse Subcooled Flow

Flow Characteristic of Steam Jet Condensed into a Water Pipe Flow - a Numerical Study

Void fraction profile in steam-water bubbly condensing flow

Flow instabilities and transient convective heat transfer in a helical coiled tube with pulsatile steam-water two phase flow

Interfacial characteristics of steam jet condensation in subcooled water pipe flow - An experimental and numerical study

Numerical Simulation Of Wet Steam Condensing Flow Based On A Two-Fluid Model

Acoustic Analogy for Multiphase or Multicomponent Flow

Frequency domain analysis of density wave oscillations for two-phase flow in a vertical tube

Prediction of Thermohydraulics in Shell Side of CAP1400 Steam Generator by Two-Fluid Porous Media Model

Numerical Investigation on Two-Phase Water Density Wave Oscillations in a Pipe under Various Heating Conditions

Numerical Analysis on Pressure Distribution for Sonic Steam Jet Condensed into Subcooled Water

Numerical study on acoustic characteristics of flow boiling in a helical tube

An experimental investigation of oscillatory heat transfer in helical coiled tube with steam water two phase density wave oscillation flow

Unsteady Numerical Simulation of Wet Steam Two-phase Flow

Experimental Study on Sonic Steam Jet Condensation in Quiescent Subcooled Water

Transient and Time-Averaged Heat Transfer of Steam Water Two-Phase Qscillatory Flow in Helical Coiled Tubing Boiler-Reactor

Experimental Study on Density-Wave Instability of High Pressure Steam-Water Two-Phase Flow in U-Type Tube