Abstract:Plate-like Ca3Ti2O7 (CT) and Nd2Ti2O7 (NT) particles were synthesized in molten salts and used as reactive templates for the preparation of highly textured (Ca0.7Nd0.3)0.87TiO3 bulk ceramics (CNT) with preferred pseudocubic 〈100〉 and 〈110〉 orientations, respectively. During flux growth CT and NT particles developed facets parallel to the pseudocubic {100} and {110} planes, respectively, in a perovskite unit cell, since those planes correspond to the interlayers of the layered perovskite-type crystal structures. Complementary reactants for the CNT stoichiometry were wet-mixed with the reactive templates and the slurries were tape-cast. Then stacked tapes were heat-treated for dense single-phase CNT ceramics with a distorted and A-site deficient regular perovskite-type structure. The CNT ceramics prepared with CT and NT reactive templates exhibited strong pseudocubic 100- and 110-family x-ray diffraction peaks, respectively, with other peaks drastically suppressed when non-perovskite sources were used as complementary reactants. The textured ceramics possess unique microstructures; as either parallel or obliquely stacked block structures with a pseudocubic {100} plane faceted. The pseudocubic {100}-and {110}-textured CNT ceramics exhibited ∼10 and ∼20% higher products of the dielectric quality factor and frequency, Q · f, respectively, than conventional ceramic sintered at the same temperature. When Q · f is compared based on the same grain size, the {100}-textured CNT exhibited 27% higher values than non-textured while relative permittivity and temperature coefficient of resonant frequency were of similar values. Simple geometrical relationships between electric field and penetrated pseudocubic {hk0}-type grain boundaries must lead to the reduced scattering and dielectric loss.

Texture Development in Na1/2bi1/2tio3-Batio3 Ceramics by Reactive-Templated Grain Growth

Texture Development in Na<sub>1/2</sub>Bi<sub>1/2</sub>TiO<sub>3</sub>-BaTiO<sub>3</sub> Ceramics by Reactive-Templated Grain Growth

Fabrication and Electrical Properties of Textured Na 1/2 Bi 1/2 TiO 3 -Batio 3 Ceramics by Reactive-Templated Grain Growth

Study On The Textured Bnkt Ceramics By Reactive Templated Grain Growth

Preparation and Characterization of Textured Bi0.5(Na0.8 K0.2)0.5TiO3 Ceramics by Reactive Templated Grain Growth

Fabrication Of Na0.5bi0.5tio3-Batio3-Textured Ceramics Templated By Plate-Like Na0.5bi0.5tio3 Particles

Study on Textured Nbt-6bt Ceramics Fabricated by (reactive) Templated Grain Growth

Fabrication of Na<sub>0.5</sub>Bi<sub>0.5</sub>TiO<sub>3</sub>-BaTiO<sub>3</sub>-Textured Ceramics Templated by Plate-Like Na<sub>0.5</sub>Bi<sub>0.5</sub>TiO<sub>3</sub>Particles

Textured Pb(Mg1/3nb2/3)O-3-Pbtio3 Ceramics By Templated Grain Growth

Textured Pb(Mg<sub>1/3</sub>Nb<sub>2/3</sub>)O<sub>3</sub>-PbTiO<sub>3</sub> Ceramics by Templated Grain Growth

Textured Pb(Mg<sub>1/3</sub>Nb<sub>2/3</sub>)O<sub>3</sub>-PbTiO<sub>3</sub> Ceramics by Templated Grain Growth

(001) Textured Pb(Mg1/3nb2/3)O-3-Pbtio3 Ceramics Prepared by Reactive Templated Grain Growth

Texture development and dielectric relaxor behavior of 0.80Na0.5Bi0.5TiO3-0.20K0.5Bi0.5TiO3 ceramics templated by plate-like NaNbO3 particles

Textured Pb(Mg1/3Nb2/3)O3-PbTiO 3 ceramics by templated grain growth

Effect of SrTiO3 Template on Electric Properties of Textured BNT–BKT Ceramics Prepared by Templated Grain Growth Process

Structure and Strain Behavior of <00l> Textured BNT-based Ceramics by Template Grain Growth

Fabrication and Electrical Properties of Textured Ba(Zr0.2Ti0.8)O3–(Ba0.7Ca0.3)TiO3 Ceramics Using Plate-Like BaTiO3 Particles As Templates

Enhanced Piezoelectric Properties and Depolarization Temperature in Textured (Bi0.5na0.5)tio3-Based Ceramics Via Homoepitaxial Templated Grain Growth

Large electric field induced strain of Bi(Mg1/2Ti1/2)O3-Pb(Mg1/3Nb2/3)O3-PbTiO3 ceramics textured by Template Grain Growth

Superior Large-Signal Piezoelectric Coefficient in Textured NBT-Based Piezoceramics by Template-Induced Structure and Composition Modulation

Texture design for microwave dielectric (Ca0.7Nd0.3)0.87TiO3 ceramics through reactive-templated grain growth

Texture Development in Na1/2bi1/2tio3-Batio3 Ceramics by Reactive-Templated Grain Growth

Texture Development in Na&lt;sub&gt;1/2&lt;/sub&gt;Bi&lt;sub&gt;1/2&lt;/sub&gt;TiO&lt;sub&gt;3&lt;/sub&gt;-BaTiO&lt;sub&gt;3&lt;/sub&gt; Ceramics by Reactive-Templated Grain Growth

Fabrication and Electrical Properties of Textured Na 1/2 Bi 1/2 TiO 3 -Batio 3 Ceramics by Reactive-Templated Grain Growth

Study On The Textured Bnkt Ceramics By Reactive Templated Grain Growth

Preparation and Characterization of Textured Bi0.5(Na0.8 K0.2)0.5TiO3 Ceramics by Reactive Templated Grain Growth

Fabrication Of Na0.5bi0.5tio3-Batio3-Textured Ceramics Templated By Plate-Like Na0.5bi0.5tio3 Particles

Study on Textured Nbt-6bt Ceramics Fabricated by (reactive) Templated Grain Growth

Fabrication of Na<sub>0.5</sub>Bi<sub>0.5</sub>TiO<sub>3</sub>-BaTiO<sub>3</sub>-Textured Ceramics Templated by Plate-Like Na<sub>0.5</sub>Bi<sub>0.5</sub>TiO<sub>3</sub>Particles

Textured Pb(Mg1/3nb2/3)O-3-Pbtio3 Ceramics By Templated Grain Growth

Textured Pb(Mg&lt;sub&gt;1/3&lt;/sub&gt;Nb&lt;sub&gt;2/3&lt;/sub&gt;)O&lt;sub&gt;3&lt;/sub&gt;-PbTiO&lt;sub&gt;3&lt;/sub&gt; Ceramics by Templated Grain Growth

Textured Pb(Mg<sub>1/3</sub>Nb<sub>2/3</sub>)O<sub>3</sub>-PbTiO<sub>3</sub> Ceramics by Templated Grain Growth

(001) Textured Pb(Mg1/3nb2/3)O-3-Pbtio3 Ceramics Prepared by Reactive Templated Grain Growth

Texture development and dielectric relaxor behavior of 0.80Na0.5Bi0.5TiO3-0.20K0.5Bi0.5TiO3 ceramics templated by plate-like NaNbO3 particles

Textured Pb(Mg1/3Nb2/3)O3-PbTiO 3 ceramics by templated grain growth

Effect of SrTiO3 Template on Electric Properties of Textured BNT–BKT Ceramics Prepared by Templated Grain Growth Process

Structure and Strain Behavior of <00l> Textured BNT-based Ceramics by Template Grain Growth

Fabrication and Electrical Properties of Textured Ba(Zr0.2Ti0.8)O3–(Ba0.7Ca0.3)TiO3 Ceramics Using Plate-Like BaTiO3 Particles As Templates

Enhanced Piezoelectric Properties and Depolarization Temperature in Textured (Bi0.5na0.5)tio3-Based Ceramics Via Homoepitaxial Templated Grain Growth

Large electric field induced strain of Bi(Mg1/2Ti1/2)O3-Pb(Mg1/3Nb2/3)O3-PbTiO3 ceramics textured by Template Grain Growth

Superior Large-Signal Piezoelectric Coefficient in Textured NBT-Based Piezoceramics by Template-Induced Structure and Composition Modulation

Texture design for microwave dielectric (Ca0.7Nd0.3)0.87TiO3 ceramics through reactive-templated grain growth

Texture Development in Na<sub>1/2</sub>Bi<sub>1/2</sub>TiO<sub>3</sub>-BaTiO<sub>3</sub> Ceramics by Reactive-Templated Grain Growth

Textured Pb(Mg<sub>1/3</sub>Nb<sub>2/3</sub>)O<sub>3</sub>-PbTiO<sub>3</sub> Ceramics by Templated Grain Growth