Abstract:Wet impregnation method has been widely adopted to synthesize the oxide substrate supported catalysts for CO2 dry reforming of CH4. However, their particle size and distribution are not stable and uniform, causing rapid particle growth and carbon deposition. Here, we show that these problems can be overcome by using a LaMnO3 (LM)-based perovskite in which 20 mol% Ni is doped (La0.9Mn0.8Ni0.2O3, LMN) and then exsolved (R-LMN) by in-situ reduction in 5%H-2-N-2 stream at 800 degrees C. The perfomance of such catalyst is compared with that of the Ni-impregnated LM (NLM) reduced under the same conditions (R-NLM). The SEM and TEM analyses reveal that the exsolved Ni nanoparticles in R-LMN are uniform in size, evenly distributed and partially embedded into and hence bonded strongly with the substrate; but the Ni particles in R-NLM are variable in size and weakly bonded with the substrate. Therefore, the particle growth (coalescence) is largely suppressed for the exsolved Ni nanoparticles in R-LMN but not for the Ni nanoparticles in R-NLM. It is also comfirmed that the Ni particles in R-NLM are lifted off from the substrate by carbon fibers formed during test. Consequently, R-LMN demonstrates high and stable conversion (above 80%) and selectivity (above 90%) with a strong resistance to carbon deposition at 700 degrees C for 24 h. But, a large amount of carbon fiber is formed with a Ni particle at the tip in tested R-NLM, resulting in rapid performance degradation. The high performance of R-LMN for CO2 dry reforming of CH4 is attributed to the stable nanosized Ni particles and LMN substrate that provides more oxygen vacancies for CO2 activation and in turn carbon oxidation.

La-based Perovskite Precursors Preparation and Its Catalytic Activity for CO2 Reforming of CH4

CO2 Reforming of CH4 over Nickel and Cobalt Catalysts Prepared from La-Based Perovskite Precursors

LaMnO3-based Perovskite with In-Situ Exsolved Ni Nanoparticles: a Highly Active, Performance Stable and Coking Resistant Catalyst for CO2 Dry Reforming of CH4

Catalytic CO2 Reforming of Methane over Perovskite Noble Metals

Perovskite La-2(Nicu)O-4 Catalyst Precursors For Dry Reforming Of Methane: Effects Of Cu-Substitution On Carbon Resistance

CO2 dry reforming of CH4 with Sr and Ni co-doped LaCrO3 perovskite catalysts

Effects of Noble Metals Doped on Mesoporous Laalni Mixed Oxide Catalyst and Identification of Carbon Deposit for Reforming Ch4 with Co2

CO2 Reforming of CH4 over Rare Earth Elements Functionalized Mesoporous Ni–Ln (ln = Ce, La, Sm, Pr)–Al–O Composite Oxides

Perovskite La<sub>2</sub>(NiCu)O<sub>4</sub> catalyst precursors for dry reforming of methane: effects of Cu-substitution on carbon resistance

Dry Reforming of Methane over Bimetallic Ni-Co Catalyst Prepared from La(CoxNi1-x)0.5Fe0.5O3 Perovskite Precursor: Catalytic Activity and Coking Resistance

LaFe0.9Ni0.1O3 Perovskite Catalyst with Enhanced Activity and Coke-Resistance for Dry Reforming of Ethane

Influences of Ni Content on the Microstructural and Catalytic Properties of Perovskite LaNixCr1−xO3 for Dry Reforming of Methane

f coal bed methane on LaCoO 3 perovskite catalyst : the structure evolution and catalytic performance

High-performance photothermal catalytic CO2 reduction to CH4 and CO by ABO3 (A = La, Ce; B = Ni, Co, Fe) perovskite nanomaterials

A highly active Ni catalyst supported on Mg-substituted LaAlO3 for carbon dioxide reforming of methane

Performance of supported nickel catalyst for reforming of CH 4 with CO 2 to syngas: II . Effect of basic promoters

Effects of Nd, Ce, and La Modification on Catalytic Performance of Ni/Sba-15 Catalyst in Co2 Reforming of Ch4

Studies on Coke Formation and Coke Species of Nickel-Based Catalysts in CO 2 Reforming of CH 4

Investigation of La Promotion Mechanism on Ni/SBA-15 Catalysts in CH4 Reforming with CO2

Supported Cobalt Catalyst Promoted by Noble Metals for CH4/CO2 Reforming to SyngasⅠ.Preparation Conditions and Performance of Pt-Co/Al2O3 Catalyst

Catalytic Performance and Characterization of Ni–CaO–ZrO2 Catalysts for Dry Reforming of Methane