Abstract:Noncovalently cross-linked hydrogels can exhibit toughness and mechanical adaptability typically associated with biological tissues, which make them promising for a variety of applications. However, molecules in the environment can interact to significantly alter the properties of these hydrogels, which could adversely impact their performance. Here, we illustrate how two common ionic surfactants, sodium dodecyl sulfate (SDS) and cetyltrimethylammonium bromide (CTAB), influence the swelling and rheological properties of hydrogel films cross-linked by hydrophobic associations based on a random copolymer of poly(N,N-dimethylacryalmide-co-2-(N-ethylperfluorooctanesulfonamido)ethyl acrylate (DMA-FOSA) using a quartz crystal microbalance with dissipation (QCM-D). The effect of the surfactants on the swelling and dissolution of these physically crosslinked hydrogels is contrasted with the effect of aqueous 2-propanol (IPA), which can dissolve the copolymer readily. The addition of IPA, SDS, and CTAB at low concentrations increases the swelling of the hydrogel film, decreases the elastic modulus, and increases the rheological phase angle (more fluidlike). A transition from swelling to (partial) dissolution occurs at higher concentrations with a threshold of approximately 7 wt % IPA, 0.1.cmc for SDS, and 0.5.cmc for CTAB to promote partial dissolution. With IPA, initial swelling is always observed immediately after the solvent is added, whereas the initial swelling can be significantly delayed with long incubation times to dissolution, on the order of hours, at low concentrations of surfactant. These results illustrate that simple ionic surfactants can dissolve these hydrophobically cross-linked hydrogels, but identification of the maximum concentration of surfactant that will not dissolve the hydrogels may be challenged by the long incubation times that increase as the concentration decreases. The long times to dissolve these thin films (initial thickness <200 nm for copolymer) suggest that stability of bulk physically cross-linked hydrogels in complex aqueous environments may be challenging to accurately assess if surfactant diffusion is the limiting factor.

Investigation on Solvent Casting Films of Surfactant-Encapsulated Clusters.

Formation of AlOOH and Silica Composite Hierarchical Nanostructures Thin Film by Sol–gel Dip-Coating for Superhydrophobic Surface with High Adhesion Force

Langmuir-Blodgett Film Formation from Surfactant-Capped Zinc Sulfide Nanoparticles Spread on Water Surface

Structural Control of Surfactant-Templated Hexagonal, Cubic, and Lamellar Mesoporous Silicate Thin Films Prepared by Spin-Casting

Study on the Origin of Inverted Phase in Drying Solution-Cast Block Copolymer Films

Delayed Swelling and Dissolution of Hydrophobically Associated Hydrogel Coatings by Dilute Aqueous Surfactants

Influences of Solution Property and Charge Density on the Self-Assembly Behavior of Water-Insoluble Polyelectrolyte Sulfonated Poly(sulphone) Sodium Salts.

Crystalline Phase Formation of Poly(vinylidene Fluoride) from Tetrahydrofuran/N,N‐dimethylformamide Mixed Solutions

Drop‐Cast Hybrid Poly(styrene)‐b‐Poly(ethylene oxide) Metal Salt Films: Solvent Evaporation and Crystallinity‐Dependent Evolution of Film Morphology

Solvent effect on the film formation and the stability of the surface properties of poly(methyl methacrylate) end-capped with fluorinated units.

Detection of Free Surface Composition and Molecular-Level Structural Development of Styrene(s)/butadiene(b) Block Copolymer Films During a Solution-to-film Process

Molecular simulation on solubilization of fullerene C60 by C12E6 nonionic surfactants

Nanostructures and multi-scale aggregation of high ion exchange capacity short-side-chain perfluorosulfonic acid dispersion

Foam Film Stratification, Viscosity, and Small-Angle X-ray Scattering of Micellar SDS Solutions over an Extended Concentration Range (1< c/CMC < 75)

The effect of surfactant chain length on the morphology of poly(methyl methacrylate) microcapsules for fragrance oil encapsulation

Preparation and Spectroscopic Study of Langmuir-Blodgett Films of 4-[4(-(4(-decyloxy Phenylazo) Naphthloxy] Butyl Trimethylamimonium Dextran Sulfate

Casting solvent effects on molecular dynamics of weak dynamic asymmetry polymer blend films via broadband dielectric spectroscopy

Surfactant-Dependent Partitioning of Organics in Aqueous-Organic Reaction Systems

THE SELF-ASSEMBLY THIN FILMS FROM WATER-SOLUABLE C60-CONTAINING POLYELECTROLYTES:SYNTHESIS,FABRICATION,AFM/FFM STUDIES

Surface segregation of fluorinated moieties on random copolymer films controlled by random-coil conformation of polymer chains in solution.

Effects of Casting Solvents on the Formation of Inverted Phase in Block Copolymer Thin Films