Abstract:A combined computational/experimental study is performed to investigate hypersonic low-density internal gas flows in a convergent-divergent nozzle over a wide range of Knudsen numbers. The numerical solutions are obtained using the direct simulation Monte Carlo (DSMC) method and the experimental measurement is conducted in the hypersonic low-density wind tunnel FengDong-19 (FD-19) at China Academy of Aerospace Aerodynamics. Rarefaction effects are found to play an important role in pressure disturbance propagation, flow separation (vortex formation), mass flow rate, velocity slip, and thermally nonequilibrium effect. Pressure disturbance propagates farther upstream with increasing free-stream Knudsen number Kn∞. Although there is no flow separation near the nozzle surface for Kn∞ = 0.1, the slip velocity is such anomalously small that it cannot suppress flow separation, thus, producing one small vortex for Kn∞ = 0.2, 0.5 and 1. Due to the presence of the continuous sheet of two-order Moffatt vortices, the skin friction coefficient does not change sign (positive to negative) in the small separated region. This indicates that the incipient and small separated flows with second-order vortices may not be discerned by examining the sign of the skin friction. As Kn∞ grows to 2, this small vortex disappears. However, with further increase in Kn∞, a large vortex nearly fills the compression section of the nozzle due to the backflow effect. As Kn∞ increases from continuum to free molecular regime, the dimensionless mass flow rate mfr/mfr∞ rises first to its maximum at Kn∞ ∼ 0.2 resulting from the weaker flow blockage effect. After the maximum point, mfr/mfr∞ dwindles first because of the stronger backflow effect and rises again to its free molecular limit, obtaining its minimum (the so-called Knudsen minimum) at Kn∞ ∼ 10. DSMC results and experimental data obtained from FD-19 wind tunnel are in good agreement, achieving a mutual validation between computation and experiment. This indicates that our experiment provides valuable data that can server as “benchmark” case to support computational code evaluation and validation.

SIMPLE and CLEAR algorithms for transonic flow

Application of simplified threeGequation transition model in hypersonic flow

Comparison of Robustness and Efficiency for Simple and Clear Algorithms with 13 High-Resolution Convection Schemes in Compressible Flows

Computation of Hypersonic Transitional Flows Over Cones Using Gas-Kinetic Scheme Coupled with the Turbulence Model

Computation of Hypersonic Flows over Flying Configurations Using a Nonlinear Constitutive Model

ACTIVE FLOW CONTROL APPLICATIONS WITH ZERO NET MASS FLUX ACTUATOR IN FLOW FIELD OF SUPERSONIC INLET

The study of different discretized schemes for density and convection terms in high speed compressible flow using the pressure-based method

Solutions for variable density low Mach number flows with a compressible pressure-based algorithm

Numerical Simulation of Three Dimensional Nozzle Flows by Using NND Difference Scheme

High-efficiency Solving Method for Steady Transonic Flow Field

Numerical Investigation of Low-Mach Number Flowfield Inside of Vaned Diffuser Based on the Pseudo Compressibility, Method

Research on Computational Method of Supersonic Inlet/Isolator Internal Flow

An Efficient and Robust Numerical Scheme for the Simpler Algorithm on Non-Orthogonal Curvilinear Coordinates: Clearer

A NOVEL SEGREGATED ALGORITHM FOR INCOMPRESSIBLE FLUID FLOW AND HEAT TRANSFER PROBLEMS--CLEAR (COUPLED AND LINKED EQUATIONS ALGORITHM REVISED) PART II: APPLICATION EXAMPLES

A conservative implicit scheme for three-dimensional steady flows of diatomic gases in all flow regimes using unstructured meshes in the physical and velocity spaces

Comparison of the SIMPLE-like algorithm for solving pressure-velocity coupling equations in steady flow problems

Modifications to the SIMPLE Algorithm with the MDCD Approach for Incompressible Flow Simulation

Numerical study on transonic flow of moist air with non-equilibrium condensation

Investigation of Compressible Flow under Low Mach Number in an Enclosed Square Cavity with a Novel Non-Boussinesq Algorithm

Numerical and Experimental Investigation of Rarefied Hypersonic Flow in a Nozzle

A Comprehensive Performance Comparison for Segregated Algorithms of Flow and Heat Transfer in Complicated Geometries