Abstract:In order to ensure that the supercritical CFB boiler has good wide-load operation characteristics and the ability of deep peak regulation， the transient heat transfer characteristics between the working fluid and the water wall under the change of transcritical pressure are experimentally studied. Experiment adopted Φ25 mm×3.5 mm vertical upward tube， the near-critical steady heat transfer experiment and the transcritical pressure step transient heat transfer experiment were carried out under the experimental conditions of 20～23 MPa of pressure and 400～800 kg/(m 2 ·s) of mass flow rate. The results showed that under the near-critical pressure， increasing the flow rate， reducing the heat flux on the inner wall， and reducing the pressure can reduce the dryness when the DNB heat transfer deterioration occurs， and increase the corresponding fluid enthalpy value， and delay the occurrence of the heat transfer deterioration. When the transcritical pressure step changes， the heat transfer deterioration may occur in the heating pipe， resulting in the wall temperature rising rapidly， but the temperature will fall back to the normal value with the increase of the flow rate. The heat transfer between the wall temperature rising point and the inner wall surface goes through the heat transfer deterioration stage， the subcooled boiling heat transfer enhancement stage and the single liquid phase heat transfer stage. The influence of each parameter on the heat transfer deterioration in the transcritical pressure step change experiment is the same as that in the near-critical steady state experiment. The decrease of flow rate and the increase of heat flux on the inner wall will advance the location of the heat transfer deterioration， and the wall temperature rise will be greater.

Study on the characteristics of heat transfer for super-heater in CDQ boiler

Study on coal combustion characteristics in a 350MW supercritical tangentially boiler

Reference temperature correction and dimensionless number analysis for heat transfer of supercritical CO2 in horizontal tubes

The Study of Unified Thermal Calculation Model of Circulating Fluidized Bed Boiler Based on Experience

Numerical simulation analysis of a heat transfer tube in SuperORV

Experimental test, numerical analysis and thermal calculation modeling of hundreds kW th -class supercritical CO 2 fossil-fired boiler system

Steam Temperature Characteristics in Boiler Water Wall Tubes Based on Furnace CFD and Hydrodynamic Coupling Model

Numerical study on heat transfer characteris tics of supercritical water in straight and helical tubes

Dynamic Behavior of Steam Temperature of Supercritical Thermal Power Units

The Thermal-Hydraulic Calculation and Analysis of the Medium Temperature Platen Superheater in A 300 Mwe Cfb Boiler

Experimental study on heat transfer deterioration of supercritical CO2 in a round tube:A boundary assessment

Experimental investigation on dynamic characteristics of water wall during transcritical process of deep peak regulation for supercritical CFB boilers

Prediction of tube temperature distribution of boiler platen superheater by a coupled combustion and hydrodynamic model

DYNAMICS STUDY ON CORROSION TEST IN GAS-PHASE HC1 FOR SUPERHEATERS OF BIOMASS BOILERS

Investigation And Modeling Of The In-Tube Heat Transfer Of Fluids At Supercritical Pressure During Heating

Modeling and Simulation of the Long-term Dynamic Characteristics of a Supercritical Once-through Boiler

Analysis of Heat Transfer Mechanism in Supercritical Fluids from the Aspect of Pool Heating

Integrated Numerical Model for Ultra/Supercritical CFB Boilers

DYNAMIC MODELING STUDY OF SUPERHEATER STEAM TEMPERATURE BASED ON PRINCIPAL COMPONENT ANALYSIS METHOD AND ONLINE DATA

Numerical Study of Supercritical Opposed Wall-Fired Boiler Furnace Temperature and High-Temperature Heating Surface Stress under Variable Load Operation

Hydrodynamic Characteristics of Vertical Tubes With Low Mass Flux in Supercritical Pulverized Coal Boiler