Abstract:Morphology development at the fiber/matrix interphase in fiber-reinforced isotactic polypropylene composites is a widely studied topic. While the application of shear flow may strongly enhance the nucleation density around the fiber, little is known about the influence of fibers on the crystallization of polypropylene subjected to an extensional flow. In this work, the flow around a single glass fiber upon uniaxial elongation of the melt is examined using X-ray scattering and diffraction techniques and compared to the response measured for the neat matrix. A comparison between a neat and compatibilized matrix is made given the strong influence of the addition of an adhesion modifier on the bulk crystallization kinetics of polypropylene. The flow is applied using an in-house-built filament stretching extensional rheometer, which, due to its midfilament control scheme, allows for in situ X-ray experiments. Combined small-angle X-ray scattering/wide-angle X-ray diffraction patterns are acquired during the flow and subsequent crystallization step. Postcrystallization area scans of the filament show that the introduction of a single glass fiber gives rise to the development of β-phase crystals, particularly in the area around the fiber ends, and in contrast to what is observed for the matrix materials alone, where solely α-phase is found. Surprisingly enough, the addition of a single fiber (0.00045 vol %) alters the crystallizing polymorph in almost the entire filament. However, the addition of the adhesion modifier hinders the formation of β-phase crystals around the fiber due to an acceleration of the bulk crystallization kinetics. Finite element simulations provide insight into the flow field around the fiber during stretching and demonstrate that the flow is no longer uniaxial extension, but dominated by shear, even though the volumetric amount of fiber as compared to the matrix is negligible. These findings explain the experimental observation of substantial β-phase formation after the introduction of a single fiber, while this is not observed in the matrix material. Worth noting, the formation of β-phase polypropylene depends not only on the presence and the strength of the flow but predominantly on the type of flow, i.e., shear as opposed to elongation.

BEHAVIOR OF A LIQUID CRYSTAL POLYMER AFTER ELONGATION FLOW TREATMENT

Effect of Monomer Structure on Crystallization and Glass Transition of Flexible Copolyesters

INFLUENCE OF THERMAL TREATMENT ON CRYSTAL MELTING BEHAVIOR AND CRYSTAL STRUCTURE OF NYLON 6 AND POLYAMIDE BLOCK COPOLYMER/NYLON 6 BLENDS

Solution Crystallization Behavior Of Crystalline-Crystalline Dibloek Copolymers Of Poly(Ethylene Oxide)-Block-Poly(Epsilon-Caprolactone)

Annealing effect of thermotropic liquid crystalline copolyester fibers on thermo-mechanical properties and morphology

Effect of Molecular Conformation Changes on the Phase Behavior of Liquid Crystalline Polymers

THERMAL EXPANSION BEHAVIOR OF ALIPHATIC POLYAMIDES

Rheological Properties Of Liquid Crystalline Copoly (P-Hydroxybenzoate/Bisphenol A Terephthalate)

Kinetics of Liquid Crystallization for Lyotropic Liquid Crystalline Polymers

The High-Pressure Crystallization and Annealing Behaviors of Polyethylene Terephthalate Oligomer

New Observation on Morphology of a Thermotropic Liquid Crystalline Polyesterimide Crystallized at High Temperature

How Flow Affects Crystallization in A Heterogeneous Polyethylene Oxide Melt

STUDY ON CRYSTALLIZATION OF POLY(ε-CAPROLACTONE) IN POLY(ε-CAPROLACTONE)/POLY(VINYL METHYL ETHER) BLENDS

Extension‐Enhanced Conductivity of Liquid Crystalline Polymer Nano‐Composites

Stretch-Induced Α-to-β Crystal Transition and Lamellae Structural Evolution of Poly(butylene Adipate-Ran-terephthalate) Aliphatic–Aromatic Copolyester

Crystallization kinetics of PBA/Nylon 6/H2SO4 solutions

Fiber-Induced Crystallization in Elongational Flows

Annealing studies on a thermotropic liquid crystalline polyester meltblown fabric

Structural evolution of ultra-high molecular weight polyethylene gel film stretching at different temperatures with reservation of shish crystals

Structural Characteristics of Fibrillar Crystals in Uniaxially Stretched Isotactic Polypropylene Dominated by Temperature and Strain

The structure of liquid crystalline aromatic copolyesters prepared from 4-hydroxybenzoic acid and 2-hydroxy-6-naphthoic acid