Abstract:The newly issued National Drinking Water Standard required that turbidity should be lower than 1 NTU, and the substitution of sand filtration by immersed ultrafiltration (immersed-UF) is feasible to achieve the standard. This study aimed to optimise the operational processes (i.e. aeration, backwashing) through pilot scale studies, to control membrane fouling while treating the sedimentation effluent. Results indicated that the immersed-UF was promising to treat the sedimentation effluent. The turbidity was below 0.10 NTU, bacteria and E. coli were not detected in the permeate water. The intermittent filtration with aeration is beneficial to inhibit membrane fouling. The critical aeration intensity is observed to be 60.0 m(3) m-(2) h(-1). At this aeration intensity, the decline rate of permeate flux in one period of backwashing was 1.94% and 7.03% for intermittent filtration and sustained filtration respectively. The different membrane backwashing methods (i.e. aeration 1.5 min, synchronous aeration and water backwashing 2 min, water backwashing 1.5 min; synchronous aeration and water backwashing 3 min, water backwashing 2 min; aeration 3 min, single water backwashing 2 min; synchronous aeration and water backwashing 5 min; single water backwashing 5 min) on the recovery of permeate flux were compared, indicating that the synchronous aeration and water backwashing exhibited best potential for permeate flux recovery. The optimal intensity of water backwashing is shown to be 90.0 L m(-2) h(-1). When the actual water intensity was below or exceeded the value, the recovery rate of permeate flux would be reduced. Additionally, the average operating cost for the immersed UF membrane, including the power, the chemical cleaning reagents, and membrane modules replacement, was about 0.31 RMB/m(3).

STUDY ON THE APPLICATION OF SUBMERGED ULTRAFILTRATION TECHNOLOGY IN FEED WATER TREATMENT

Coupling Continuous Sand Filtration to Ultrafiltration for Drinking Water Treatment: Improved Performance and Membrane Fouling Control

Comparative Study on Different Processes and Ultrafiltration for Surface Water Treatment

In-line Coagulation/Ultrafiltration Process for Advanced Treatment of Reclaimed Water

Integrated process of nanofiltration for treating tidal salty water from Qiantang River

STUDY OF COMBINED ULTRAFILTRATION AND DISINFECTION OF THE TREATED WATER

Combined Technique of Enhanced Coagulation and Ultrofiltration on the Treatment of the Micro-Polluted Xiangjiang River Source -- the Comparing Studies Adopting Different Coagulants

PILOT-SCALE STUDY ON IMMERSED ULTRAFILTRATION PROCESS FOR SEDIMENTATION EFFLUENT TREATMENT

Ultrafiltration of Yangtze River water

Study of drinking water treatment by ultrafiltration of surface water and its application to China

Pilot Study on Advanced Treatment of Yangtze River Raw Water by Ultrafiltration Membrane

Research on the current situation of ultrafiltration combined process in treatment of micro-polluted surface water

Pilot Submerged Ultrafiltration Membrane Processes in Drinking Water Treatment

The substitution of sand filtration by immersed-UF for surface water treatment: Pilot-scale studies

A pilot study for the treatment of micro-polluted water by ultrafiltration-nanofiltration process

Comparative Study of Conventional and Combined Process (immobilized Microorganisms Pretreatment - Ultrafiltration) for Surface Water Treatment

Pilot Study on Short-flow Ultrafiltration Processes for Treatment of Dongjiang River Water

Evaluation of ultrafiltration membrane combination process in Nanjiao Waterworks

Drinking Water Production by Ultrafiltration of Songhuajiang River with PAC Adsorption

Pilot study on the shortened process by ultrafiltration adapting to conventional coagulation/sedimentation for drinking water treatment

Pilot Study on Submerged Ultra -Filtration Substituting Sand Filtration for Drinking Water Treatment from Dongjiang River