Abstract:At present, despite the great advances in polymer electrolyte membrane fuel cell (PEMFC) technology over the past two decades through intensive research and development activities, their large-scale commercialization is still hampered by their higher materials cost and lower reliability and durability. In this review, water management is given special consideration. Water management is of vital importance to achieve maximum performance and durability from PEMFCs. On the one hand, to maintain good proton conductivity, the relative humidity of inlet gases is typically held at a large value to ensure that the membrane remains fully hydrated. On the other hand, the pores of the catalyst layer (CL) and the gas diffusion layer (GDL) are frequently flooded by excessive liquid water, resulting in a higher mass transport resistance. Thus, a subtle equilibrium has to be maintained between membrane drying and liquid water flooding to prevent fuel cell degradation and guarantee a high performance level, which is the essential problem of water management. This paper presents a comprehensive review of the state-of-the-art studies of water management, including the experimental methods and modeling and simulation for the characterization of water management and the water management strategies. As one important aspect of water management, water flooding has been extensively studied during the last two decades. Herein, the causes, detection, effects on cell performance and mitigation strategies of water flooding are overviewed in detail. In the end of the paper the emphasis is given to: (i) the delicate equilibrium of membrane drying vs. water flooding in water management; (ii) determining which phenomenon is principally responsible for the deterioration of the PEMFC performance, the flooding of the porous electrode or the gas channels in the bipolar plate, and (iii) what measures should be taken to prevent water flooding from happening in PEMFCs.

A review on water balance in the membrane electrode assembly of proton exchange membrane fuel cells

A review of proton exchange membrane fuel cell water management: Membrane electrode assembly

Review On Water Management Methods For Proton Exchange Membrane Fuel Cells

A Review Of Water Management In Polymer Electrolyte Membrane Fuel Cells

Investigation of Water and Heat Transfer Mechanism in PEMFCs Based on a Two-Phase Non-Isothermal Model

Modeling Water and Thermal Transients Inside Proton Exchange Membrane for Vehicle Application Fuel Cells

Optimization Strategies and Diagnostic Techniques for Water Management in Proton Exchange Membrane Fuel Cells

Interfacial Water Management of Gradient Microporous Layer for Self-Humidifying Proton Exchange Membrane Fuel Cells

Experimental and Model Refinement of Water Content and Membrane Conductivity in Reinforced Composite Proton Exchange Membranes

Investigating the Effects of Multi-Dimensional Parameters on the Internal Hydrothermal Characteristics of Proton Exchange Membrane Fuel Cells Via an Enhanced Impedance Dimensional Model

A three-dimensional PEM fuel cell model with consistent treatment of water transport in MEA

A Review of the Transition Region of Membrane Electrode Assembly of Proton Exchange Membrane Fuel Cells: Design, Degradation, and Mitigation

A review of the microporous layer in proton exchange membrane fuel cells: Materials and structural designs based on water transport mechanism

Research Status of Water Management of Proton Exchange Membrane Fuel Cells

A Review of Membranes in Proton Exchange Membrane Fuel Cells: Transport Phenomena, Performance and Durability

Quantitative Performance Analysis of Anion-Exchange Membrane Fuel Cells with In-Plane and Through-Plane Water Transport

Modeling of the Effect of Ionomer Volume Fraction on Water Management for Proton Exchange Membrane Fuel Cell

A review of water flooding issues in the proton exchange membrane fuel cell

Advancements and insights in thermal and water management of proton exchange membrane fuel cells: Challenges and prospects

Research progress in water buildup of proton exchange membrane fuel cell

Analysis of Water Management in Proton Exchange Membrane Fuel Cells