Abstract:An investigation on biohydrogen production was conducted in a granular sludge-based continuous stirred tank reactor (CSTR). The reactor performance was assessed at five different glucose concentrations of 2.5, 5, 10, 20 and 40g/L and four hydraulic retention times (HRTs) of 0.25, 0.5, 1 and 2h, resulting in the organic loading rates (OLRs) ranged between 2.5 and 20g-glucose/Lh. Carbon flow was traced by analyzing the composition of gaseous and soluble metabolites as well as the cell yield. Butyrate, acetate and ethanol were found to be the major soluble metabolite products in the biochemical synthesis of hydrogen. Carbon balance analysis showed that more than half of the glucose carbon was converted into unidentified soluble products at an OLR of 2.5g-glucose/Lh. It was found that high hydrogen yields corresponded to a sludge loading rate in between 0.6 and 0.8g-glucose/g-VSSh. Substantial suppression in hydrogen yield was noted as the sludge loading rate fell beyond the optimum range. It is deduced that decreasing the sludge loading rate induced the metabolic shift of biochemical reactions at an OLR of 2.5g-glucose/Lh, which resulted in a substantial reduction in hydrogen yield to 0.36–0.41mol-H2/mol-glucose. Optimal operation conditions for peak hydrogen yield (1.84mol-H2/mol-glucose) and hydrogen production rate (3.26L/Lh) were achieved at an OLR of 20g-glucose/Lh, which corresponded to an HRT of 0.5h and an influent glucose concentration of 10g/L. Influence of HRT and substrate concentration on the reactor performance was interrelated and the adverse impact on hydrogen production was noted as substrate concentration was higher than 20g/L or HRT was shorter than 0.5h. The experimental study indicated that a higher OLR derived from appropriate HRTs and substrate concentrations was desirable for hydrogen production in such a granule-based CSTR.

Biohydrogen Production with Anaerobic Sludge Immobilized by Granular Activated Carbon in a Continuous Stirred-Tank

Continuous Bio-Hydrogen Production Using Activated Carbon As Solid Carriers from Molasses Fermentation

Biological hydrogen production in continuous stirred tank reactor systems with suspended and attached microbial growth

Continuous Biohydrogen Production from Diluted Molasses in an Anaerobic Contact Reactor

Continuous Treatment of Hydrothermal Liquefaction Wastewater in an Anaerobic Biofilm Reactor: Potential Role of Granular Activated Carbon

Biohydrogen Production from Ethanol-Type Fermentation of Molasses in an Expanded Granular Sludge Bed (EGSB) Reactor

Production of hydrogen in a granular sludge-based anaerobic continuous stirred tank reactor

Fermentative hydrogen production from molasses wastewater in a continuous mixed immobilized sludge reactor.

[Continuous Operation of Hydrogen Bio-Production Reactor with Ethanol-Type Fermentation].

Fermentative Hydrogen Production from Beet Sugar Factory Wastewater Treatment in a Continuous Stirred Tank Reactor Using Anaerobic Mixed Consortia

Metabolic Pathways of Hydrogen Production in Fermentative Acidogenic Microflora

[Characteristics and Operation of Enhanced Continuous Bio-Hydrogen Production Reactor Using Support Carrier].

Hydrogen-producing Capability of Anaerobic Activated Sludge in Three Types of Fermentations in a Continuous Stirred-Tank Reactor

Operation characteristics of biohydrogen production in continuous flow anaerobic system for treating wastewater of beet-sugar processing

Start-up and Performance of Anaerobic Contact Reactor for Hydrogen Production

Start-up and Continuous Operation of Bio-Hydrogen Production Reactor at Ph 5

Simultaneous biohydrogen production and starch wastewater treatment in an acidogenic expanded granular sludge bed reactor by mixed culture for long-term operation

Biohydrogen Production from Molasses by Anaerobic Fermentation with a Pilot-Scale Bioreactor System

Biohydrogen production, sludge granulation, and microbial community in an anaerobic inner cycle biohydrogen production (AICHP) reactor at different hydraulic retention times

CONTINUOUS OPERATION AND HYDROGEN PRODUCTION CHARACTERISTICS OF A NOVEL HYDROGEN PRODUCTION REACTOR

Anaerobic Biohydrogen Production from Monosaccharides by a Mixed Microbial Community Culture.