Abstract:<p>As an efficient heat transfer enhancement element, 3-D finned tube has good potential in the field of waste heat utilization of industrial flue gas. However, the industrial flue gas often contains a large amount of ash particles. Meanwhile, ash deposition on the surface of heat exchanger can worsen the heat transfer performance and even shorten the service life of the heat exchanger. Therefore, the research of coupling effect of heat transfer and ash deposition on 3-D finned tube heat exchanger is very necessary, and it is bound to affect the further promotion and application of 3-D finned tube heat exchanger. In this paper, the influence of ash deposition on heat transfer process of 3-D finned tube heat exchanger was further studied. The effects of ash deposition time on heat transfer rate and relative pressure drop were discussed firstly. It was found that both ofheat transfer and relative pressure drop basically tended to be stable with the running time up to 6 hours. Then, the influences of fin height of 3-D finned tube, gas velocity and particle concentration on fouling characteristics, heat transfer and flow performance were studied according to the orthogonal array design method. The optimized parameters corresponding to the smallest fouling coefficient and the least relative pressure drop after fouling were determined. Besides, the performance of 3-D finned tube heat exchanger with the optimized parameters was also compared with other tested heat exchangers. The results showed that the heat exchanger with optimized parameters had better heat transfer performance than the other cases under the same condition. At last, a correlation of fouling coefficient of 3-D finned tube heat exchanger under the optimized parameters with ash deposition time was obtained, and it can be useful in the design and evaluation of heat exchanger in dusty environment.</p>

Experimental Study on Anti-abrasion and Anti-ash-deposition Property of Spirally Finned Tubes

An experimental study of gas–solid flow around helically finned tube

Experimental study of two-phase flow inside finned-tubes separator using 3-D-PDA

Numerical and experimental study of finned tube erosion protection methods

Numerical Simulation of Erosion Characteristics on Gas-solid Flow Across H-type Finned Tube

Experimental Investigation on Influence of Fin Structures on Particle Deposition and Pressure Drop of Fin-and-tube Heat Exchangers

To Characterize Two-Phase Flows Around a Finned Tube Using the Three-Dimensional Particle Dynamics Analyzer (PDA) and Numerical Calculation

Experimental investigation on particle deposition characteristics of wavy fin-and-tube heat exchangers

Experimental Study on the Pressure Drop and Heat Transfer of Two Different Tubes With Plain-Rectangle Internal Fins

A Numerical Study of a Protection Technique Against Tube Erosion

Experimental Study on the Pressure Drop and Heat Transfer Characteristics of Tubes with Internal Wave-Like Longitudinal Fins

Experimental Study of Particle Deposition Characteristics on Wavy Finned-tube Heat Exchanger

To characterize two-phase flows around finned tube by using 3D-PDA and numerical calculation

Experimental Research of CFB Ash Deposition on Helical Finned Tubes

Experimental and numerical investigation on flow and heat transfer characteristics of a multi-waves internally spiral finned tube

Convective Heat Transfer and Pressure Drop of Annular Tubes with Three Different Internal Longitudinal Fins

Numerical Study of the Solid Particle Erosion on H-Type Finned Circular/Elliptic Tube Surface

Heat transfer and pressure drop characteristics of 3-D finned tube heat exchanger in ash-laden flue gas

Experimental Study of Heat Transfer and Pressure Drop for H-type Finned Oval Tube with Longitudinal Vortex Generators and Dimples under Flue Gas

Influence of Wet-Particle Deposition on Air-Side Heat Transfer and Pressure Drop of Fin-and-tube Heat Exchangers

Computational analysis of heat transfer and pressure drop performance for internally finned tubes with three different longitudinal wavy fins