Abstract:Nowadays, the zero liquid discharge of flue gas desulfurization (FGD) wastewater from coal-fired units has attracted the attention of all countries in the world. The pretreatment methods generally have the problems of high operation cost, small treatment capacity, and poor flexibility. However, the membrane method can avoid the above problems. In the current research, it has not been found that someone directly uses submerged ultrafiltration to pretreat FGD wastewater. Therefore, this paper innovatively proposed to directly use ceramic ultrafiltration membrane to treat FGD wastewater, which can ensure effluent quality and improve the flexibility of the pretreatment system. In this paper, the performance of submerged ultrafiltration membrane for the filtration of FGD wastewater from a power plant was studied to optimize the filtration performance and improve the effluent quality. The effects of operating parameters such as membrane permeate flux, aeration rate and filtration/backwashing time combination on the membrane performance were studied. The results showed that when the filtration/backwashing time combination was 15 min/30 s, with the increased in permeate flux from 55 L/(m2·h) to 100 L/(m2·h), the steady transmembrane pressure (TMP) increased from 39 kPa to 70 kPa, and the fouling rate increased significantly from 4.5 kPa/h to 7.3 kPa/h; When the aeration rate increased from 10 m3/(m2·h) to 30 m3/(m2·h), the membrane pollution was much reduced. Excessive aeration rate cannot further alleviate the membrane pollution, but also brought greater energy consumption; Increasing backwashing time can effectively inhibit the formation of gel layer on the surface of the membrane and prolong the initial stage of low-pressure operation; The rejection of suspended solids (SS) and turbidity of the equipment studied in this paper can reach more than 99% under various working conditions, which can satisfy the water quality requirements of the subsequent steps. The submerged ultrafiltration membrane was suitable for the pretreatment of FGD wastewater because it can ensure the quality of permeate under the premise of long-term operation.

Application of ultrafiltration membrane and granular activated carbon processes for wastewater reclamation

WASTEWATER REUTILIZATION BY MEMBRANE TECHNOLOGY IN MECHANICAL TREATMENT

Application of Double Membrane Technology for Advanced Treatment of Municipal Reclaimed Water in Saline Area

Characteristics and application of multiple membrane process in plating wastewater reutilization

Wastewater treatment and reutilization by membrane technology in mechanical industry

A Field Study of Advanced Municipal Wastewater Treatment Technology for Artificial Groundwater Recharge

Design and Operation of MBR Process of Water Reclamation Project

Treatment and Reuse of Glass-fiber Wastewater Using Refined Diatomite Physicochemical Treatment and Biological Aerated Filter

DYEING WASTEWATER TREATMENT AND REUTILIZATION THROUGH ULTRAFILTRATION AND NANOFILTRATION INTEGRATED MEMBRANE PROCESSES

An integrated wastewater reuse concept combining natural reclamation techniques, membrane filtration and metal oxide adsorption

Integrated Aerobic Granular Sludge and Membrane Process for Enabling Municipal Wastewater Treatment and Reuse Water Production

The Application of the Integrated Technology of Flocculation Combined with Precoating Filtration in Wastewater Reuse

Using reclaimed water as make-up water for a district heating system: a case study in Beijing.

Critical Fundamental Scientific Problems in Reclamation and Reuse of Municipal Wastewater

Removal efficiencies of organic micropollutants in wastewater-based reclaimed water by two different treatment processes

Improving the Performance of the Reverse Osmosis Process with Fiber Filter and Ultrafiltration: Promoting Municipal Sewage Reclamation and Reuse for Industrial Processes

Assessing the wastewater reclaim system consisted of wastewater plant - hybrid constructed wetland - ultra filtration and reverse osmosis in a chemical industrial park, a multi-criteria decision-making analysis

Development of an integrated aerobic granular sludge MBR and reverse osmosis process for municipal wastewater reclamation

Study on Water Quality Stabilization Technology for Reclaimed Wastewater As Landscape-Environmental Water by Using Aquatic Plant System

Removal of Organic Pollutants in Municipal Wastewater for Artificial Groundwater Recharge

Application of Submerged Ultrafiltration in Pretreatment of Flue Gas Desulfurization Wastewater