Abstract:The crystallization technology is one of the most potential ways to produce para-xylene (PX) with high purity, but it has some drawbacks such as low yield and difficult to control crystallization due to the insufficient study of the PX nucleation characteristics and growth behavior. To further investigate this issue, this paper couples the Euler-Euler model and population balance equation (PBE) model, correlates the PX crystallization kinetics, and accurately solves the PBE using the Gaussian integral hypothesis and product difference algorithm, which innovatively and directly simulates the PX suspension crystallization process and yields its multiphysical field characteristics. A multiobjective genetic algorithm is then used to study and optimize the crystallization mechanism and variation patterns, and the PX crystallization amplification law is derived. The results can be concluded as follows. There is a complete internal circulation flow in the crystallizer, and the fluid near the stirring paddle, at the entrance, and at the bottom has the strongest molecular kinetic energy and mixing degree. The crystal concentration and size increase exponentially before 750 s of crystallization, after which the growth trend decreases and gradually reaches dynamic equilibrium. The inlet velocity and stirring speed are inversely connected with the average particle size and particle size distribution interval, while supersaturation is positively correlated with both. The supersaturation has the most obvious effect on the crystal size distribution (CSD) curve. In comparison to the original settings, the optimized operating parameters raise the average particle size of PX by 6.68% and decrease the distribution interval by 38.21%. At last, the sedimentation velocity can be employed as an amplification factor to simplify the amplification process. This paper might serve as a theoretical reference for PX crystallization research and process optimization.

Study on initial crystallization point of cytidine monophosphate based on crystallization kinetics model

Model and Numerical Simulation for Adsorption Phase Reaction and Crystallization

A Study on Process Modeling and Optimization for Batch Crystallization

Mechanism and kinetic modeling study on the crystallization of concomitant polymorphs

Crystallization solvent design based on a new quantitative prediction model of crystal morphology

A Modified Method for Modelling, Optimization and Control of an Anti-Solvent Crystallization Process

Kinetics modeling for intermediate and final stages of unseeded crystallization

Study on the Nucleation Kinetics of DL-methionine Based on the Metastable Zone Width of Unseeded Batch Crystallization

Crystallization Kinetics and Mechanisms of Calcium Sulfate Dihydrate: Experimental Investigation and Theoretical Analysis

Simulation of Polymer Crystallization under Isothermal and Temperature Gradient Conditions Using Particle Level Set Method

Multiscale Modeling and Simulation of Polymer Crystallization in Cooling Stage

Effects of the concentration of seeds, finite time-dependent supersaturations, and viscosity on the crystallization kinetics of monosodium urate monohydrate

Modeling and dynamic simulation of batch crystallization process

Intensive Research on the Nucleation Induction Time in Cooling Crystallization of the Myo-inositol-Water System: Data Measurement and Establishment of Prediction Models

Advances in modeling and dynamic optimization of batch crystallization

Digital Design of an Agrochemical Crystallization Process via Two-Dimensional Population Balance Modeling

Prediction of Metastable Zone Widths: Optimizing the Nucleation Potential Model with Solid–Liquid Interfacial Energy

CFD-PBE Simulation of Para-Xylene Crystallization Behavior and Process Amplification under Different Operating Conditions

Modeling and Optimization of the Para-Xylene Continuous Suspension Crystallization Separation Process via a Morphology Technique and a Multi-Dimensional Population Balance Equation

Simulation and On-line Real-time Measurement of Aspirin Crystalline Particle Size Distribution Based on Ultrasound

Measurement of Disodium 5'‐inosinate and Disodium 5'‐guanylate in Aqueous Ethanol by Attenuated Total Reflection Ultraviolet Method