Abstract:This paper addresses the problem of small fault detection from closed-loop control for discrete-time nonlinear uncertain systems. The problem is challenging due to (i) the considered system is subject to unstructured nonlinear uncertain dynamics; (ii) the faults are considered to be “small” in the sense that system states and control inputs in faulty mode remain close to those in normal mode; and (iii) fault detection needs to be accomplished during closed-loop control which might counteract the fault effects and thus diminish fault information for detection use. To overcome these challenges, a novel adaptive dynamics learning based fault detection scheme is proposed. Specifically, a new concept of fault dynamics residual is first developed to extract and represent enhanced fault information from closed-loop control. Then, an ideal estimator is constructed by using absolute measures of the proposed fault dynamics residuals. To make the ideal estimator implementable for systems with nonlinear uncertain dynamics, an adaptive dynamics learning approach is subsequently proposed to achieve the locally-accurate approximation of the uncertain fault dynamics. Finally, an adaptive threshold is developed based on the actual estimation system for real-time decision making, i.e., the fault is claimed to be detected when the associated residual signal becomes larger than the adaptive threshold. Rigorous analysis is performed to deduce the small fault detectability condition, which is shown to be significantly relaxed compared to those of existing fault detection methods. Extensive simulations have also been conducted to demonstrate the effectiveness and advantages of the proposed approach.

Application of a New Fault Detection Approach to Aerocraft's Closed-Loop Control System

A Mixed H2/H∞ Approach to Integrated Fault Diagnostic and Fault-Tolerant Control

Small Fault Detection from Discrete-Time Closed-Loop Control Using Fault Dynamics Residuals.

Improved Threshold for the Local Approach in Detecting Faults

Sliding Mode Fault-Tolerant Control for Nonlinear High-Order Fully Actuated Systems

Active Robust Fault-Tolerant H∞ Control Design Based on an Adaptive Fault Observer

Robust fault-tolerant H-infinity control based on LMI approach and application in satellite attitude control system

Identification-based Sensor and Actuator Fault Diagnosis for Industrial Control Systems and Its Application to HTR-PM

Fault Diagnosis and Fault-Tolerant Control for Sampled-Data Attitude Control Systems: an Indirect Approach

Adaptive Fault-Tolerant Robust Control for A Linear System with Adaptive Fault Identification

Fault-Tolerant Control For Over-Actuated Systems With Actuator Fault And Input Saturation

An integrated design method for active fault diagnosis and control

Robust Fault Detection and Diagnosis for Uncertain Nonlinear Systems

Integrated Adaptive Fault-Tolerant H Infinity Output Feedback Control with Adaptive Fault Identification

Fault Identification for a Closed-Loop Control System Based on an Improved Deep Neural Network

Integrated Design of Fault Estimation and Fault-Tolerant Control for Closed-Loop Systems With Uncertain Short Delay

ToMFIR-based Detection and Estimation for Incipient Actuator Faults in a Class of Closed-Loop Nonlinear Systems

Robust Fault Detection of Networked Control Systems: An Improved LMJ Approach

Fault Detection and Fault-Tolerant Control for Delta Operator Systems

Adaptive fault‐tolerant control for aircraft against control surface failure diagnosed by set‐membership estimation

Application of H<sub>&#x0221E;</sub> robust fault-tolerant control in satellite attitude control system